Basler Electric DGC-2020 - Manual (Page 599)

Fault
Code
Number
String Description
500 AL WIRING POM STARTER
1 A wiring fault has been detected in the connection of starter 1 of POM.
501 AL WIRING POM STARTER
2 A wiring fault has been detected in the connection of starter 2 of POM.
502 AL OPEN LD POM
ALTRNATR An open load on POM’s alternator output has been detected.
503 AL BATT NOT CHARGING Battery is not being charged by alternator.
504 AL CAN POM NODE LOST POM is missing on CAN bus.
505 AL NEW POM FOUND New POM found.
506 AL LOW STARTER VOLTS Battery voltage is too low for starting.
507 AL POM ERROR A general POM error has been detected.
508 AL WRONG POM ID POM sends a different identification number (ID) than expected.
509 AL CHECK POM FUSE Check POM fuse.
510 AL OVERRIDE APPLIED Override applied.
511 HIHI P CHG MIX A Hi Charge Air Mix A Pressure (Limit 2).
512 HIHI P CHG MIX B Hi Charge Air Mix B Pressure (Limit 2).
513 SD P COOLNT DIFF Sensor Defect In Coolant Differential Pressure Sensor.
514 WRITE ERR FLASH Write Error Occurred when writing data to Flash Memory.
515 STARTER NOT ENGAGED Starter of POM could not be engaged.
516 OILNIVEAU CAL ERR Remote Oil Level Watchman Calibration Error.
517 SD CHG MX PR THRT Sensor Defect In Charge Pre-Throttle Mix Pressure Sensor.
518 SD THROT BYPASS FDBK Sensor Defect In Throttle Feedback Bypass Sensor.
519 OIL LVL CAL ERROR Oil Level Calibration Error.
520 SD P IN AIR AFT FLT A Sensor Defect In Intake Air After Filter A Pressure Sensor.
521 SD P OIL MID VAL Lube Oil Pressure Middle Value (Limit 2).
522 SD P IN AIR AFT FLT B Sensor Defect In Intake Air After Filter B Pressure Sensor.
523 SD T COOL RED MIDVL Coolant Temperature Mid value (Limit 2).
524 SS ENG OVRSPD MIDVL Engine Speed Middle Value too high (Limit 2).
525 SD P LUBE OIL R2 Sensor Defect In Lube Oil Pressure (R2) Sensor.
526 SD T COOL OIL R2 Sensor Defect In Oil Coolant Temperature (R2) Sensor.
527 TD ENG SPD SNS DEV Engine Speed Sensor Deviation.
528 SD ENG SPD SENSR 3 Sensor Defect in Engine Speed Third Sensor.
529 SS T COOL RED 2 Coolant Temperature Red 2 Alarm (Limit 2).
530 SS P LUBE OIL RED 2 Lube Oil Pressure Red 2 Alarm (Limit 2).
531 AL WIRING PWM CM1 PWM CM1 Wiring Issue.
532 AL WIRING PWM1 PWM 1 Wiring Issue.
533 AL WIRING PWM2 PWM 2 Wiring Issue.
534 HIHI POWER DIFF Power Difference High (Limit 2).
535 LOLO POWER DIFF Power Difference Low (Limit 2).
536 AL WIRING PWM1 CM1 PWM CM1 Wiring Issue.
537 SD P VNTRI DLTA SD A Sensor Defect In Venture Side A Delta Pressure Sensor.
538 SD P VNTRI DLTA SD B Sensor Defect In Venture Side B Delta Pressure Sensor.
539 SD P EGR VNTRI STATIC Sensor Defect In EGR Venture Static Pressure Sensor.
540 SD T EGR Sensor Defect In EGR Temperature Sensor.
541 AL L1 T EGR EGR Temperature (Limit 1) Alarm.
542 AL L2 T EGR EGR Temperature (Limit 2) Alarm.
9400200990 Rev X DGC-2020 MTU Fault Codes D-9