INFICON HAPSITE Smart Plus Chemical Identification System User Manual
Page 26

TOC - 12
IP
N 07
4-
47
2-
P1
C
HAPSITE Smart Plus Operating Manual
Communications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-5
When to Use the Service Module. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-6
Plus IQ Software for the Service Module . . . . . . . . . . . . . . . . . . . . . . . . . . 15-7
The Service Module Tab in Properties Window . . . . . . . . . . . . . . . . . . . . . 15-8
Starting Up HAPSITE on the Service Module . . . . . . . . . . . . . . . . . . . . . 15-11
Attaching the HAPSITE to the Service Module . . . . . . . . . . . . . . . . . . . . 15-12
Attaching the HAPSITE to the Service Module using the
Plus IQ Software . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-13
Attaching the HAPSITE to the Service Module using the
HAPSITE Front Panel Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-15
Detaching the HAPSITE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-17
Using Plus IQ Software to Detach . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-17
Using the Front Panel Display to Detach . . . . . . . . . . . . . . . . . . . . . . . . . 15-19
Physically Removing the HAPSITE from the Service Module . . . . . . . . . 15-19
Storing the Service Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-20
When Power to the Service Module is Lost . . . . . . . . . . . . . . . . . . . . . . . 15-23
Maintenance
Introduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-1
Safety Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-2
HAPSITE Symptom - Cause - Remedy Chart . . . . . . . . . . . . . . . . . . . . . . 16-3
Required Environment for General Maintenance . . . . . . . . . . . . . . . . . . . . 16-7
Contamination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-7
Contamination of the Mass Spectrometer . . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Symptoms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Decontamination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Contamination of the Gas Chromatograph. . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Symptoms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Decontamination . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-8
Contamination of the Probe and Probe Line . . . . . . . . . . . . . . . . . . . . . . . 16-9
Symptoms . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-9
Decontaminate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-9
Decontaminating the Outside of the Analytical Module . . . . . . . . . . . . . . 16-11
NEG Pump Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-15
NEG Pump Bakeout Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-17
Bakeout Using the Laptop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-17
Bakeout From Front Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-18
Reactivating the NEG Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-19
Reactivation Using the Laptop . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16-19