Functions speed range – JLG X23J - X700AJ Service Manual User Manual
Page 17
SECTION 1 - SPECIFICATIONS
3121448
– JLG Lift –
1-9
1.5 FUNCTION SPEEDS
Machine Orientation When Doing Speed
Tests
Lift: Boom Retracted. Telescope Retracted. Lift Up,
Record Time, Lift Down, Record Time.
Swing: Machine stabilized, upper Boom at Full Elevation.
Telescope Retracted. Swing the Turntable to the end stop.
Swing the Opposite Direction, Record Time.
Telescope: Boom at Full Elevation; Telescope Retracted;
Telescope Out, Record Time. Telescope In, Record Time.
Drive: Test to be done on a smooth level surface. Drive
Select Switch should be set at 2WD High Engine. Start
approximately 25 ft. (7.62 m) from starting point so that
the unit is at maximum speed when starting the test.
Results should be recorded for a 100 ft. (30.96 m) course.
Drive Forward, record time. Drive Reverse, Record Time.
Platform Rotate: Platform level and completely rotated
one direction. Rotate the opposite direction, Record Time.
Rotate the other direction, Record Time.
Articulating Jib: Platform level and centered with the
boom. Start with the Jib down. Jib Up, Record Time. Jib
Down, Record Time.
Lower Lift: Upper Boom horizontal. Telescoped In. Lower
Lift Up, Record Time. Lower Lift Down, Record Time.
TEST NOTES
1. Stop watch should be started with the function, not
with the controller or switch.
2. All speed tests are run from ground with remote con-
trol connected on the basket.
3. Function speeds may vary due to cold, thick hydrau-
lic oil. Test should be run with the oil temperature
above 100° F (38° C).
Table 1-13. Functions speed (in seconds)
FUNCTIONS SPEED RANGE
FUNCTION
TIME Sec
X14J
X390AJ
TIME Sec
X17J
TIME Sec
X19J
X550AJ
TIME Sec
X23J
X700AJ
TELESCOPE EXTEND
21" - 23"
26" - 30"
21" - 23"
45" - 65"
TELESCOPE RETRACT
13" - 15"
16" - 20"
16" - 18"
29" - 45"
TOWER BOOM UP
18" - 21"
24" - 28"
28" - 30"
50" - 60"
TOWER BOOM DOWN
16" - 20"
24" - 28"
27" - 29"
56" - 70"
UPPER BOOM UP
25" - 27"
24" - 28"
29" - 31"
48" - 57"
UPPER BOOM DOWN
25" - 27"
24" - 28"
31" - 33"
60" - 70"
BASKET ROTATE RIGTH
//
9" - 13"
7" - 9"
7" - 9"
BASKET ROTATE LEFT
//
9" - 13"
7" - 9"
7" - 9"
SWING LEFT
1':00" - 1.06"
58" - 62"
41" - 47"
1':20" - 1.40"
SWING RIGTH
1':00" - 1.06"
58" - 62"
41" - 47"
1':20" - 1.40"
JIB UP
8.5" - 10"
6" - 10"
16" - 25"
14" - 25"
JIB DOWN
8.5" - 10"
7" - 11"
11" -13"
10" - 13"
BASKET LEVEL UP
7" - 11"
11" - 15"
37" - 39"
37" - 39"
BASKET LEVEL DOWN
10" - 13"
9" - 15"
27" - 29"
27" - 37"
Drive Forward /Reverse
Low Speed m/s
0.39"
0.47"
0.47"
0.28"
High Speed m/s
0.78"
0.92"
0.92"
0.47"