Rockwell Automation 284 ArmorStart User Manual - Manual (Page 9)

Table of Contents v
Mapping Consumed Data to the DeviceLogix Data Table. .............12-3
Finding ZIP bits in Device Logix Editor .........................................12-12
Chapter 13
Diagnostics Overview ......................................................................................13-1
Protection Programming ........................................................13-1
Fault Display ................................................................................13-1
Clear Fault ...................................................................................13-2
Fault Codes ..................................................................................13-2
Fault Definitions ...........................................................................13-3
Short Circuit ..........................................................................13-3
Overload Trip .........................................................................13-3
Phase Loss ............................................................................13-3
Phase Short............................................................................13-3
Shorted SCR...........................................................................13-3
Ground Fault ..........................................................................13-3
Stall .......................................................................................13-3
Control Power ........................................................................13-3
I/O Fault ................................................................................13-3
Over Temperature .................................................................13-4
Phase Imbalance ...................................................................13-4
Over Current...........................................................................13-4
DeviceNet™ Power Loss .......................................................13-4
Internal Communication Fault .................................................13-4
DC Bus Fault ..........................................................................13-4
EEPROM Fault .......................................................................13-4
Hardware Fault ......................................................................13-4
Restart Retries .......................................................................13-4
Miscellaneous Faults ..............................................................13-4
Chapter 14
Troubleshooting Introduction ..................................................................................14-1
Bulletin 280/281 Troubleshooting..................................................14-2
Bulletin 283 Troubleshooting.........................................................14-4
Bulletin 284 Troubleshooting.........................................................14-8
DeviceNet Troubleshooting Procedures ......................................14-14
ArmorPoint Backplane Troubleshooting Procedures ....................14-15
Control Module Replacement ......................................................14-16
Base Module Replacement ..........................................................14-19
Appendix A
Specifications Bulletin 280/281 Specifications.......................................................A-1
Bulletin 283 Specifications ..............................................................A-4
Bulletin 284 Specifications ..............................................................A-9
ArmorConnect™ Three-Phase Power Media ................................A-14
Trunk Cables .........................................................................A-14
Drop Cables ..........................................................................A-15
Power Tees & Reducer ..........................................................A-16
Power Receptacles ................................................................A-18
ArmorConnect Control Power Media .............................................A-20
Trunk & Drop Cables .............................................................A-20
T-Ports ..................................................................................A-21