Replacements and adjustments, Filter strainer replacement, Adjusting belts (suction pumps only) – Gasboy Atlas Start-up User Manual
Page 218: Replacements and adjustments -4, Warning
Improperly installed or maintained equipment can create a hazard.
Improperly installed or maintained equipment could cause a fire, explosion, or electrical shock.
For any component not supplied by Gasboy Atlas (for example, hoses and nozzles), consult and
follow the installation and maintenance instructions provided by the manufacturer.
WARNING
Preventive Maintenance and Inspection
Replacements and Adjustments
Page 9-4
MDE-4334D Atlas™ Start-up and Service Manual · July 2013
Replacements and Adjustments
Filter Strainer Replacement
If the unit is equipped with a strainer and filter, check and change it at regular intervals
(refer to
“Preventive Maintenance Table”
). A dirty strainer and/or filter in a pump
or remote dispenser will cause a slower delivery rate. To ensure that you replace the strainer
and filter required with the one designed for your model, refer to the accessories section of
your parts manual. Always use a drip pan and absorbent material directly below the filter when
removing the cartridge, to prevent contamination of both soil and electrical components within
the cabinet. This service must not be performed by untrained individuals.
Special Setup Required for Aircraft Fueling
Aircraft require finely filtered fuel.
Improperly filtered fuel could cause the engine to fail.
Do not use Gasboy Atlas pumps/dispensers without auxiliary filters, separators, and other
equipment required to ensure product purity, for direct fueling of the aircraft.
WARNING
Adjusting Belts (Suction Pumps Only)
With proper care, belts will give exceptionally good service. A loose or overtightened belt not
only cuts down dispensing speed due to slipping, it also results in excessive wear of pump
and/or motor bearings causing premature failures. Refer to
“Preventive Maintenance Table”
on
. This service must not be performed by untrained individuals.
Leaking fuel can be ignited, causing a fire or explosion.
Fire, explosion, or electrical shock could result in severe injury or death if you continue to use
damaged pumps/dispensers.
If you find any leaks or damage, stop using the pump/dispenser.
WARNING