Warning – Gasboy Atlas Start-up User Manual
Page 217
MDE-4334D Atlas™ Start-up and Service Manual · July 2013
Page 9-3
Performing Inspections
Preventive Maintenance and Inspection
General Inspections
Note: For more information, refer to MDE-4363 Atlas Fuel Systems Owner’s Manual.
Perform a general inspection of each pump/dispenser as follows:
• Every week, to verify if all pumps/dispensers are operating properly
• Whenever you receive a complaint about potential unit problems
Leaking fuel can be ignited, causing a fire or explosion.
Fire, explosion, or electrical shock could result in severe injury or death if you continue to use
damaged pumps/dispensers.
If you find any leaks or damage, stop using the pump/dispenser.
WARNING
WARNING
Personnel servicing a pump/dispenser can be injured if the pump/dispenser is not barricaded to all
unauthorized personnel and vehicles.
If proper precautions are not taken, the person servicing the unit can be injured by a vehicle.
Before servicing a pump/dispenser, evacuate all unauthorized persons and vehicles, and then use
your vehicle, safety tape, or cones as barricades.
As part of the general inspection, inspect all areas for signs of damage or sharp edges. Replace
any missing or damaged warning labels. Gasboy also strongly recommends that an ASC
periodically inspects the equipment, as outlined in the next sub-section.
Component Inspections
To schedule component inspections, refer to
“Preventive Maintenance Table”
on
.
The station owner must only inspect for problems. For safety reasons, several tasks in the
“Preventive Maintenance Table”
on
including all repairs, must be performed only by
an ASC. To determine the tasks performed by an ASC, refer to the column entitled
“Who Performs the Inspection/Repair”
WARNING
The pump/dispenser contains pressurized flammable fuel and lethal voltages.
Servicing a Gasboy Atlas unit incorrectly could result in severe injury or death.
Do not attempt to service Gasboy Atlas pumps/dispensers yourself and do not allow untrained
personnel to service Gasboy Atlas pumps/dispensers. Only Gasboy Atlas-trained ASCs must
service a Gasboy Atlas unit.
WARNING
WARNING
You are performing inspection and maintenance in a potentially dangerous environment of
flammable fuels/vapors and high voltage.
Fire, explosion, or electrical shock could result in severe injury or death if you do not follow safety
procedures.
Read and obey all safety precautions in this manual to prevent potential injury or death.