Cable specification – MTS FlexTest Models 200 User Manual
Page 59

Model 494.41 Single-Station System Board
MTS FlexTest® Models 40/60/100/200 Controller Hardware
FlexTest Controller Configurations
59
J28 HSM Connections for the Model 494.41 System Board
HSM control (off/low/high or proportional) is software configurable. The Model
494.41 Board provides separate 24-volt, low-pressure and high-pressure outputs
that drive the HSM low- and high-pressure solenoids. Proportional control
provides a current output from 0 to 0.78 A.
Note
The Model 494.41 Board cannot be used with 115 V AC HSMs.
Applications that use 115 V AC HSMs require an external converter box
(such as a Model 413.08), which is used with this board.
Cable specification
To maintain EMC compliance, J25 HPU cables must comply with the following
specifications:
Connector—4-contact, CPC-4P, male EMI connector.
Proportional Control Cable—18 AWG, 2-conductor with foil shield with the
drain wire connected to pin 3 of the CPC connector.
Off/low/high Control Cable—18 AWG, 3-conductor with foil shield with the
drain wire connected to pin 3 of the CPC connector.
494.41 System I/O Board
J28 HSM
1
4
2
3
+24V
HSM Low
Solenoid
HSM High
Solenoid
High
Low
494.41 System I/O Board
J28 HSM
4
2
3
HSM Proportional
Control
Current
Amplifier
Power
100-240 VAC
50-60 Hz, 1-2 A
DA Output
J24
1 2 3 4 5 6 7 8
1 2 3 4 5 6 7 8
J54 Dig In
J49
Aux Pwr
J25 Hpu
Dig Out J55
Intlk J43
E-stop J29
J28 HSM
LAN 2
LAN 1
DEBUG
MOT
O
ROLA
10/100 BASE T 10/100 BASE T
SCSI
BUSY
PIB
BUSY
PCI MEZZANINE CARD
PCI MEZZANINE CARD
(Off/Low/High HSM Control)
(Proportional HSM Control)
J28 HSM