MacDon M205 Operators Manual - Manual (Page 427)

6 Troubleshooting
6.1 Engine Troubleshooting
Symptom Problem Solution Section
Move GSL to NEUTRAL.
Move steering wheel to locked
position.
Starting the
Engine, page 152
Controls not in NEUTRAL
Disengage header drive switch.
4.4.4 Header
Drive, page 190
NEUTRAL Interlock
misadjusted
Contact Dealer. Contact Dealer.
No fuel to engine
Fill empty fuel tank. Replace clogged
filter.
Filling Fuel Tank,
page 155
and
Maintaining Fuel
Filters, page 327
Old fuel in tank Drain tank. Refill with fresh fuel.
Water, dirt, or air in fuel
system
Drain, flush, fill, and prime system.
Fuel System, page
326
Improper type of fuel
Use proper fuel for operating
conditions.
Fuel
Specifications,
page 284
Crankcase oil too heavy Use recommended oil.
Lubricants, Fluids,
and System
Capacities, page
285
Low battery output
Have battery tested. Check battery
electrolyte level.
Poor battery connection Clean and tighten loose connections.
Battery, page 350
Faulty starter Contact Dealer. Contact Dealer.
Loose electrical connection
at fuel pump Ensure connector at pump is fully
pushed in.
Contact Dealer.
Wiring shorted, circuit breaker
open Check continuity of wiring and breaker
(manual reset).
ECM fuse (1 of 2) blown
ECM Ignition relay faulty
NEUTRAL Logic relay faulty
Replace.
Checking and
Replacing Fuses,
page 379
Engine hard to
start or will not
start
Faulty injectors Contact Dealer. Contact Dealer.
169887 411 Revision A