Rockwell Automation 1757-SWKIT5100 ProcessLogix R510.0 Installation and Upgrade Guide User Manual
Page 7

Publication 1757-IN510A-EN-P - October 2003
Table of Contents v
Changing Hosts File Entries . . . . . . . . . . . . . . . . . . . . . 5-26
Station Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-29
Creating Emergency Repair Disks . . . . . . . . . . . . . . . . . 5-34
Checking Control Builder Operation and Logging On . . 5-34
Additional Redundant Server
Procedures
Adding Redundancy to R510.0 Non-Redundant
Server Systems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6-2
Changing the Computer Name on a ProcessLogix Server 6-2
Changing Hosts File Entries . . . . . . . . . . . . . . . . . . . . . 6-3
Changing TCP/IP address on a Secondary
Setting up Primary Server (SERVERA). . . . . . . . . . . . . . . . . 6-6
Making Redundant Hardware File Entries . . . . . . . . . . . 6-7
Configuring the Time Service . . . . . . . . . . . . . . . . . . . . 6-9
Restarting ProcessLogix Services . . . . . . . . . . . . . . . . . . 6-9
Setting Up Secondary Server (SERVERB) . . . . . . . . . . . . . . 6-9
Making Redundant Hardware File Entries . . . . . . . . . . . 6-9
Configuring the Time Service . . . . . . . . . . . . . . . . . . . . 6-10
Restarting ProcessLogix Services . . . . . . . . . . . . . . . . . . 6-10
Confirming Data Link is Available. . . . . . . . . . . . . . . . . 6-10
Configuring Stations in Quick Builder (on SERVERA) . . . . . 6-11
Setting Up Station on SERVERA . . . . . . . . . . . . . . . . . . . . . 6-12
Setting Up Station on SERVERB . . . . . . . . . . . . . . . . . . . . . 6-15
Setting up the Redundant ERDB . . . . . . . . . . . . . . . . . . . . 6-18
Restarting Redundant Servers. . . . . . . . . . . . . . . . . . . . . . . 6-19
Synchronizing Server Databases on Redundant Server . . . . 6-20
Confirming Databases are Synchronized . . . . . . . . . . . . 6-20
Synchronizing Other Files . . . . . . . . . . . . . . . . . . . . . . 6-22
Upgrading Hardware Component Firmware . . . . . . . . . . . . 6-22
Checking Control Builder Operation and Logging On . . 6-22
Backing Up a ProcessLogix Server Hard Drive to Tape . 6-23
Creating an Emergency Repair Disk . . . . . . . . . . . . . . . 6-23
Firmware Maintenance
Procedures
1784-PCIC Driver Installation . . . . . . . . . . . . . . . . . . . . . . . 7-1
Install Hardware Device Drivers . . . . . . . . . . . . . . . . . . 7-1
Verify the 1784-PCIC Driver Version . . . . . . . . . . . . . . . 7-2
1784-PCIC Firmware Installation . . . . . . . . . . . . . . . . . . . . 7-3
Upgrading Hardware Component Firmware . . . . . . . . . . . . 7-4
About Firmware Upgrades . . . . . . . . . . . . . . . . . . . . . . 7-4
Firmware Revision Level Reference . . . . . . . . . . . . . . . . . . 7-5