SkyTrak 3606 Service Manual - Manual (Page 148)

Section 8A
8A-2
Introduction
Legend
DISCLAIMER AND SCOPE
These instructions are written for worldwide use. In
territories where legal requirements govern engine
smoke emission, noise, safety factors, etc., apply all
instructions, data and dimensions provided herein in
such a way that after maintenance, service and repair
of the engine, engine operation does not violate local
regulations.
IMPORTANT: These instructions cover only the routine
maintenance, removal, installation and troubleshooting
of the engine. Refer to the local Perkins Engine Distrib-
utor and the applicable Perkins or Perkins Phaser/
Detroit Diesel Phaser/1000 Series engine service man-
ual for assistance with comprehensive engine diagno-
sis, repair and component replacement.
A gradual running in (break in) of a new engine is not
necessary. Full load can be applied to a new engine as
soon as the engine is put into service and the coolant
temperature is at least 140° F (60°C). Extended light-
load operation during the early life of the engine is not
recommended. DO NOT run the engine at high, no-load
speeds. DO NOT apply an overload to the engine.
Throughout this section, the left or right side of the
engine is as viewed from the flywheel end.
Model 3606 • Origin 10/99
1. Perkins 1004-series Engine
2. Fan Belt
3. Ten-blade, 18"-Suction Fan
4. Alternator, 65 Amp
5. Hex-lock Elastic Nut, 7/16-14
6. Rebound Washer, 7/16"
7. Rear Left Side Engine Mount
8. Engine Mount
9. Hex-head Capscrew,
3/8-16 X 1-1/2, Grade 5
10. Flat Narrow Washer, 3/8"
11. Hex-lock Elastic Nut, 3/8-16
12. Flat Narrow Washer, 7/16"
13. Hex-head Capscrew,
7/16-14 X 3-1/4", Grade 8
14. Hex-head Capscrew,
5/8-11 X 4", Grade 8
15. Flat Narrow Washer, 5/8"
16. Engine Mount
17. Front Left Side Engine Mount
18. Hex-head Capscrew,
M12-1,75 X 40 mm Pc 8,8
19. Lockwasher, M12
20. Rebound Washer, 5/8"
21. Hex-lock Elastic Nut, 5/8-11
22. Engine Oil Filter
23. Starter
24. Front Right Side Engine Mount
25. Hex-head Capscrew,
1/4-20 X 3/4"
26. Starter Relay
27. Hex-lock Elastic Nut, 1/4-20
28. Rear Right Side Engine Mount
29. Engine Block Heater