Reznor ZQYRA Unit Installation Manual - Manual (Page 72)

Form I-ZQYRA P/N 260414R5, Page 72
INDEX
A
Measuring Airflow 60
Airflow / Pressure Drop Tables 61
Indoor Air Quality (VOC) Sensor, Option
CN7C 20
C
CFM Range 12, 16
Clearances 5
CO2 Sensor, Option CN7B 20
Coils and Tubing 66
Communication Cards 52
Compressor Controller 69
Condensate Drain 13
Condensate Pan and Drain 66
Control Option CN5, “Manual On/Off
Switch” 26
Control Option CN7D, Occupancy
Motion Sensor 27
Control Points 34
Control Wiring (field-installed) 18, 20
Corner Weights 5
Crankcase Heater 17
D
Digital Control Signal Wiring 19
Curb and Duct Opening Dimensions 8
Dimensions 4
Disconnect Switch 14
Display Menus 34
Duct Connections 12
E
Electrical Compartment 16
Electric Heating Elements 18
Subcooling 65
SUMMARY MENU 34
Superheat 65
Supply Voltage 14
Supply Wiring 15
Supply Wiring Connections 15
Dirty Filter Switch 57
Wall Start/Stop Switch, Option CN5 19
T
Test Mode Control 57
Time Clock Wall Switch, Option CN7A
19, 20
Troubleshooting 67, 68
TYPE 5 - CO2 Sensor 27
U
Uncrating 4
V
Voltage Imbalance 14
Voltage Supply 14
W
Warning labels 2
Warranty 3
Weights 5
Adjust Seals on Energy Recovery
Wheel 64
Energy Recovery Wheel 17
Removing, Cleaning, and Replacing
Wheel Segments 63
Wheel Cassette 63
Wheel Control 29
Wheel Drive Components 64
WHEEL MENU 47
Wheel Seals 64
Wiring by Control Option 19
Installer: Name ________________________________________________________
Company _______________________________________________________
Address ________________________________________________________
________________________________________________________
Phone _________________________________
Distributor (company from which the unit was purchased):
Contact ________________________________________________________
Company ________________________________________________________
Address ________________________________________________________
________________________________________________________
Phone _________________________________
Model No. ______________ Serial No._____________________Date of Installation _______________
SPECIFIC INSTALLATION NOTES: (i.e. Location, CFM, HP, Static Pressure, Amps, Temperature, Voltage, Adjustments, Warranty, etc.)
________________________________________________________________________________________
________________________________________________________________________________________
________________________________________________________________________________________
BUILDING OWNER OR MAINTENANCE PERSONNEL:
For service or repair
•
Contact the installer listed above.
•
If you need additional assistance, contact
the Reznor ® Distributor listed above.
•
For more information, contact your Reznor ®
Representative by calling 800-695-1901.
INSTALLATION RECORD - to be completed by the installer:
www.ReznorHVAC.com; (800) 695-1901
©2014 Reznor, LLC. All rights reserved.
Trademark Notes: Reznor ® is registered in at least the United States.
All other trademarks are the property of their respective owners.
0514 (Serial No. Date Code BNE) Form I-ZQYRA (Version B.1)
F
Factory Setpoints 59
FAN MENU 47
Fan Motors 16
Inlet and Exhaust Fans 62
Dirty Filter Alarm 57
Inlet and Return Air Filters 62
H
HAZARD INTENSITY LEVELS 2
Heat Pump Compressor & Controls 17
Heat Pump Controls 29
Heat Pump Maintenance 65, 66
HEAT PUMP MENU 47, 48, 49
Exhaust Hood Assembly 10
Inlet Hood Assembly 10
I
Indoor Installation 5, 12
Inlet Air Hood 10
Installation Codes 3
INSTALLER MUST COMPLETE 72
L
Lifting 5, 6
Location 3
Locations of Components 16
M
MAIN MENUS 35, 36
MAIN PAGE (Home Screen 34
Maintenance Procedures 62
Maintenance Schedule 62
MCA and MOP 15
MENUS 34
Mounting 5, 6, 8
Moving 3
O
Occupancy Control Options by
Controller Setting TYPE 26, 28
Occupancy Switch, Option CN7D 21
Option Identification 70
P
Optional Electric Preheat 18
PreHeat Control, Option PH1A and
PH2A 30
Pressure Drop (“w.c.) Tables by Size
and Fan 61
Pressure/Temperature Chart for
Checking Superheat & Subcooling
65
Q
QUICK SETPOINTS MENUS 36
R
Receiving 3
Refrigrant Charge and Check 66
Remote Mounted Unit Display, Option
RB5 22
Installing Roof Curb Option CJ3C 7, 8
S
Safeties, Alarms, and Lockouts 30
Setting Schedule 52
SCHEDULE MENU 37
Inlet and Exhaust Screens 62
Sequence of Operation 26
SERVICE MENU 37
Setting Fans to Test and Balance
Airflow 59
Setting the Fan Speeds 59, 60
Startup Form 57
Startup Requirements 57
Reznor, LLC
150 McKinley Avenue
Mercer, PA 16137