Gasboy Atlas Fuel Systems Owner Manual - Manual (Page 72)

The Atlas Fuel System Preventive Maintenance
Page 68 MDE-4363F Atlas™ Fuel Systems Owner’s Manual · September 2011
Nozzle hooks and shafts Every six months 1 Lubricate with silicone spray, if required.
2 Inspect for damage.
3 Verify that the locking tab locator is not broken. (The locking
tab locator helps hold the nozzle in the nozzle boot and
enables the station owner to lock the nozzle boot with a
clasp padlock).
4 If repair is required, call an ASC.
• Owner—Inspect
• ASC only—Repair
and test
Mechanical computers Every six months Lubricate well. See VeederRoot manuals for lubrication points. ASC only
Door locks Every six months
or if door locks
become difficult
to open and
close Lubricate with a graphite lubricant or lock oil. Follow
manufacturer’s instructions. Do not over-lubricate. Use a rag to
wipe any excess that may drip. Owner
Water in Tank After every fuel
tank fill-up Remove with a sump pump
1
Gasboy recommends removing power to the unit before
performing these inspections and process.
2 Block off the pump/dispenser to prevent customers from
operating the pump/dispenser during procedure.
3 Access and Insert sump pump into tank and draw off water.
• Owner—Inspect
• ASC only—Repair
and test
Components
Recommended
Frequency
Recommended Maintenance
Who Performs the
Inspection/Repair
WARNING
The pump/dispenser contains pressurized flammable fuel and lethal
voltages.
Servicing a Gasboy unit incorrectly could result in severe injury or death.
Do not attempt to service Gasboy pump/dispenser yourself and do not
allow untrained personnel to service Gasboy pumps/dispensers. Only
Gasboy-trained ASCs must service a Gasboy unit.
WARNING
The pump/dispenser contains pressurized flammable fuel and lethal
voltages.
Servicing a Gasboy unit incorrectly could result in severe injury or death.
Do not attempt to service Gasboy pump/dispenser yourself and do not
allow untrained personnel to service Gasboy pumps/dispensers. Only
Gasboy-trained ASCs must service a Gasboy unit.