Buhler 2180 - Manual (Page 222)

SECTION 3 - LUBRICATION AND MAINTENANCE
3-34
EVERY 300 HOURS
OPERATION 36
CHECK BATTERY ELECTROLYTE LEVEL
Check electrolyte level with the engine stopped,
tractor on level ground, and the batteries cold.
To check:
1. Remove battery box cover.
2. Clean the top of the batteries with a damp cloth.
3. Remove the six fill plugs, 1, from each battery.
4. Check that the electrolyte level is 6 mm (1/4″)
below the filler neck of each cell.
5. Add distilled or demineralized water as required.
Do not overfill.
6. Replace all fill plugs.
7. Check for loose cable connections, 2, or loose
battery clamps, 3. Tighten as required.
8. Replace battery cover.
WARNING
Batteries contain sulfuric acid. In case of
contact with skin, flush the affected area with
water for five minutes. Seek medical attention
immediately.
Avoid contact with the skin, eyes or cloth-
ing. Wear eye protection when working near
batteries.
60
OPERATION 37
DRAIN FUEL TANK
To drain the fuel tank, 2:
1. Park the tractor with the front wheels on a slight
upgrade and block the wheels front and back.
2. Open drain cock, 1, until water and sediment are
eliminated. Catch the fuel in a suitable container
and dispose of the fuel properly.
3. Close the drain cock when clean fuel appears.
2
1
61