Ditch Witch JT25 - Manual (Page 177)

Service - 176
JT25 Operator’s Manual
50 Hour
CMW
Check Radiator
Check radiator for dirt, grass, and other debris
every 50 hours. Check more often if operating in
dusty or grassy conditions. Clean as needed.
To clean:
• Clean fins with compressed air or spray wash.
• Open rear hood and spray through radiator
toward engine.
• If grease and oil are present on radiator, spray
with solvent and allow to soak overnight.
Change Hydraulic Filters (Initial
Service)
Change hydraulic filter after first 50 hours. Replace
filter every 500 hours thereafter. Change filter more
often if indicated by filter indicator.
Check Ground Drive Gearbox Oil Level
Check oil level in both ground drive gearboxes
every 50 hours. Rotate plug (shown) until level with
center of gearbox. Open plug. If oil does not come
out, add MPL as needed. Never fill more than
halfway.
IMPORTANT: Be careful not to damage fins
with high pressure air or water.
IMPORTANT: If hydraulic system must be
opened for repair, install new filter (p/n 153-791)
for first 50 hours of operation. If this filter
becomes plugged in fewer than 20 hours,
replace with new filter. After 50 hours of normal
operation, replace with new filter (p/n 153-792).
j37om030h.eps j37om030h.eps
j37om031h.eps j37om031h.eps
j37om052h.eps j37om052h.eps