JLG 4017RS Service Manual User Manual
Service manual, Models
This manual is related to the following products:
Table of contents
Document Outline
- 31200940_A_3614RS 4017RS_JLG_Service
- Effectivity Page
- Table of Contents
- Section 1 Safety Practices
- Section 2 General Information and Specifications
- Section 3 Boom
- 3.1 Boom System Component Terminology - 3614RS
- 3.2 Boom System - 3614RS
- 3.3 Boom Assembly Maintenance - 3614RS
- 3.4 Boom Chain Removal/Installation - 3614RS
- 3.5 Tilt and Auxiliary Circuit Hose Removal/Installation - 3614RS
- 3.6 Extend/Retract Cylinder Removal/ Installation - 3614RS
- 3.7 Boom Sections Adjustment - 3614RS
- 3.8 Boom System Component Terminology - 4017RS
- 3.9 Boom System - 4017RS
- 3.10 Boom Assembly Maintenance - 4017RS
- 3.10.1 Boom Removal
- 3.10.2 Second, Third and Fourth Boom Section Removal
- 3.10.3 Third and Fourth Boom Section Removal
- 3.10.4 Fourth Boom Section Removal
- 3.10.5 Fourth Boom Section Removal Only
- 3.10.6 Hose Carrier Removal/Installation
- 3.10.7 Fourth Boom Section Installation Only
- 3.10.8 Fourth Boom Section Installation
- 3.10.9 Third and Fourth Boom Section Installation
- 3.10.10 Second, Third and Fourth Boom Section Installation
- 3.10.11 Complete Boom Installation
- 3.11 Hose Carrier Assembly
- 3.12 Bottom Tilt and Auxiliary Circuit Hose Removal/Installation - 4017RS
- 3.13 Boom Chain Removal/Installation - 4017RS
- 3.14 Boom Sections Adjustment - 4017RS
- 3.15 Boom Extend and Retract Chains - 3614RS & 4017RS
- 3.16 Boom Wear Pads
- 3.17 Quick Coupler
- 3.18 Forks
- 3.19 Boom Prop (If Equipped)
- 3.20 Emergency Boom Lowering Procedure
- 3.21 Troubleshooting
- Section 4 Cab
- Section 5 Axles, Drive Shafts, Wheels and Tires
- 5.1 Axle, Drive Shaft and Wheel Component Terminology
- 5.2 Axle Serial Number
- 5.3 Axle Specifications and Maintenance Information
- 5.4 Axle Replacement
- 5.5 Brake Inspection
- 5.6 Park Brake adjustment - 3614RS
- 5.7 Steering Angle Adjustment
- 5.8 Axle Assembly and Drive Shaft Troubleshooting
- 5.9 Drive Shafts
- 5.10 Wheels and Tires
- 5.11 Towing a Disabled Machine
- Section 6 Transmission
- Section 7 Engine
- Section 8 Hydraulic System
- 8.1 Hydraulic Component Terminology
- 8.2 Safety Information
- 8.3 Specifications
- 8.4 Hydraulic Pressure Diagnosis
- 8.5 Hydraulic Circuits
- 8.6 Hydraulic Schematics
- 8.7 Hydraulic Reservoir
- 8.8 Engine Implement Pump
- 8.9 Control Valves
- 8.9.1 Main Control Valve
- 8.9.2 Service Brake Valve
- 8.9.3 Service Brake Bleeding
- 8.9.4 Service Brake Test
- 8.9.5 Steering Orbitrol Valve
- 8.9.6 Outrigger/Stabilizer Valve and Brake Damper
- 8.9.7 Brake Damper
- 8.9.8 Brake Damper Charging
- 8.9.9 Pre-Charging Damper
- 8.9.10 Checking Pre-Charge
- 8.9.11 Steer Select Valve
- 8.10 Hydraulic Cylinders
- Section 9 Electrical System
- 9.1 Electrical Component Terminology
- 9.2 Specifications
- 9.3 Safety Information
- 9.4 Power Distribution Board
- 9.5 Electrical System Schematics
- 9.6 Engine Start Circuit
- 9.7 Wiper/Washer Wiper Motor
- 9.8 Solenoids, Sensors and Senders
- 9.9 Dash Switches
- 9.10 Load Stability Indicator (LSI)
- 9.11 Hand Held Analyzer
- 9.12 Fault Codes
- 9.13 Machine Fault Codes