Vollrath GRANDE In-Chamber Vacuum Pack Machines - Manual (Page 30)

30
VACUUM PACKING MACHINE
CONDITIONNEUSE SOUS VIDE
MAQUINA DE VACÍO
Operating and service manual / Mode d’emploi et d’entretien
Manual de uso y mantenimiento / Ed. 01 - 2011
REV. 00 - Cod.: 1500386
EN
MEDIO - GRANDE
Before each start up
Weekly
Every 3500
operating cycles (about 100
hours of service)
Every two oil changes
Every 12 months
Check the oil colour and level; top up the level, or
change it completely if the colour is dark or whitish.
Check to make sure it is intact, replace if damaged
(Contact a specialist Service Centre).
Check to make sure it is intact; if cracks or stre-
aks are present, contact Customer service for
replacement.
Check to make sure they are inserted properly in
their seats; replace if damaged.
Clean to remove impurities, oil and grease.
Check to make sure it is connected.
Clean the upper part with a damp cloth.
Check dehumidification cycle.
Change the pump oil
(call a specialist Service Centre).
Change the pump exhaust filter (A)
(call a specialist Service Centre).
Change the pump oil.
(call a specialist Service Centre).
Pump
Power cable
Plexiglas cover
Silicone
and Plexiglas cover gasket
Machine and vacuum chamber
Sealing bar connection wire
Sealing bar
Pump
Pump
Pump
Pump
FREQUENCY MACHINE PART ACTION
7.2 PROGRAMMED MAINTENANCE
7.3 CARE AND CLEANING OF THE VACUUM PACKAGING MACHINE
MAINTENANCE
A
ELECTRIC HAZARD!
Danger of electric shock ! Remove the ma-
chine plug from the power socket. Do not use
water or steam jets.
DANGER! Danger of burns: if alcohol-ba-
sed or inflammable disinfectant products
are used, ventilate the area. Do not use naked
flames near the machine! Do not smoke!
ATTENTION! Danger of injury! Use personal
protective equipment. Do not use caustic
products, acids or aggressive products such
as muriatic acid. Read the instructions on the
detergent product or disinfectant pack carefully.
WARNINGS! Use alcohol-based disin-
fectants.The machine must be cleaned and
disinfected every time after use.
A