Blodgett BLCP - Manual (Page 50)

48
Maintenance
Cleaning & Preventative maintenance
DAiLY CLeAninG
Daily cleaning of your Combi oven is essential for sanita-
tion, and to ensure against operational difficulties.
Cleaning the exterior
1. The exterior of the appliance may be cleaned and
kept in good condition with a light oil. Saturate a cloth
and wipe the appliance when it is cold; wipe dry with
a clean cloth.
WARninG!!
Do noT spray the outside of the appliance
with water or clean with a water jet. Cleaning
with a water jet can impregnate chlorides into
the stainless steel, causing the onset of corro-
sion.
Cleaning the interior
NOTE: DO NOT use corrosive cleaners not intended for
oven cleaning on your Combi oven.
Blodgett recommends the following products for cleaning
and rinsing of your Blodgett Combi oven. If you choose
to use products other than what Blodgett recommends,
please have your suppler send us the MSDS sheet on the
proposed alternate so we can ensure it meets our stan-
dards. Non approved products can cause harm to your
unit and can potentially void your warranty.
Recommended oven cleaners:
Johnson Diversey Suma Nova L-6
• Four, 1 gallon (3.78 litre) containers
Product code 57252280
• One, 5 gallon (18.9 litre) container
Product code 57252100
Recommended Rinse Aid:
Johnson Diversey Suma Maro A8.8
• Four, 1 gallon (3.78 litre) containers
Product code 57270280
• One, 5 gallon (18.9 litre) container
Product code 57270100
1. Open the oven door.
2. Use the attached spray hose, located beneath the
control, to clean the front drip tray. Water will run to
the drain in the oven cavity.
Run the CombiWash automatic cleaning cycle as fol-
lows:
1. Check that the oven cleaner and rinse agent contain-
ers are both full.
2. From the WORK menu, select the clean cycle. The
CombiWash menu is displayed.
3. CombiWash features four different cleaning cycles.
Use the Left and Right Arrow keys to select the de-
sired cleaning cycle.
Step 1 (44 minutes)
Step 2 (1 hour)
Step 3 (1 hour, 49 minutes)
Step 4 (2 hours, 38 minutes)
NOTE: Use Steps 1 or 2 after steaming and roast-
ing at low temperatures. Use Steps 3 or 4
after steaming and roasting at high tempera-
tures.
4. Press the Start/Stop key to initiate the clean cycle.
5. If the cavity temperature is above 175ºF (80ºC), the
oven will automatically enter cool down. When the
cavity is below 175ºF (80ºC) the CombiWash cycle
begins.
6. The control counts down the time remaining in the
wash cycle.
7. When the wash cycle is over, the oven automatically
switches to an energy saving standby mode.