beautypg.com

Scotsman CME506R AutoIQ User Manual

Introduction

background image

Introduction:

This product manual contains the information

needed for the setup, installation, initial start up,

sanitation and maintenance of this ice machine.

Keep it for future reference.
There are 3 models covered in this manual:

CME506R, a 115 volt, dual evaporator

machine

CME656R and CME806R, 230 volt, dual

evaporator machines

Be certain that the information applies to the model

in question. If no model is listed, the information

applies to all models, including A and D series.
This manual is organized in the same way as the

expected use of the machine, it begins with

specifications, goes thru unpacking and setup,

shows where everything is; continues with initial

start up, then describes how it works. After that is

the sanitation section, followed by service

diagnosis and repair.

CME506R, 656R, 806R: AutoIQ Cubers

January 2000

Page 1

Table Of Contents

Specifications: . . . . . . . . . . . . page 2

Pre-Installation . . . . . . . . . . . . page 3

Location: . . . . . . . . . . . . . . page 4

Stacking: . . . . . . . . . . . . . . page 5

Remote Condenser Location . . . . . . . page 6

For The Installer: Remote Condenser . . . page 7

Coupling Instructions . . . . . . . . . . page 8

Electrical: . . . . . . . . . . . . . . page 9

Electrical Connections: KCMR230 Fan Relay Kit

(CME656R & CME806R only) . . . . . . page 10

Plumbing: . . . . . . . . . . . . . . page 11

After Utility Connections: . . . . . . . . page 12

Component Location and Function: . . . . page 13

AutoIQ Controller: . . . . . . . . . . . page 14

Initial Start Up: . . . . . . . . . . . . page 15

Adjustments: . . . . . . . . . . . . . page 16

Adjustments: . . . . . . . . . . . . . page 17

How To Operate The AutoIQ Controller . . page 18

How The Electronic Cuber Works . . . . . page 19

Technicians Only: Freeze Cycle Operational Sequence

. . . . . . . . . . . . . . . . . . page 20

Technicians Only: Harvest Cycle Operational Sequence

. . . . . . . . . . . . . . . . . . page 21

Sanitation and Cleaning . . . . . . . . page 22

Additional Maintenance . . . . . . . . . page 23

Additional Maintenance: Water Distributors . page 24

Additional Maintenance: Inlet Water Valve Screen

. . . . . . . . . . . . . . . . . . page 25

Additional Maintenance: Bin Controls, Condenser

. . . . . . . . . . . . . . . . . . page 26

Service Diagnosis: Controller Diagnostic Light Analysis

. . . . . . . . . . . . . . . . . . page 27

Service Diagnosis . . . . . . . . . . . page 28

Service Diagnosis: Components . . . . . page 29

Service Diagnosis . . . . . . . . . . . page 30

PTCR Diagnosis . . . . . . . . . . . page 31

Operational Characteristics: CME506R . . . page 32

Operational Characteristics: CME656R . . . page 33

Operational Characteristics: CME806R . . . page 34

Removal and Replacement . . . . . . . page 35

Removal and Replacement . . . . . . . page 36

Removal and Replacement: AutoIQ Controller page 37

Removal and Replacement: Water Level Sensor

. . . . . . . . . . . . . . . . . . page 38

Removal and Replacement: . . . . . . . page 39

Access Valves: . . . . . . . . . . . . page 40

Before Calling for Service . . . . . . . . page 41

This manual is related to the following products: