Scotsman CME1356 - Manual

INTRODUCTION
This product manual contains the information
needed for the setup, installation, initial start up,
sanitation and maintenance of this ice machine.
Keep it for future reference.
There are 2 models covered in this manual:
• CME1356, having 5 evaporators
• CME1656, having 6 evaporators
Be certain that the information applies to the model
in question. If no model is listed, the information
applies to all models.
This manual is organized in the same way as the
expected use of the machine, it begins with
specifications, goes thru unpacking and setup,
shows where everything is; continues with initial
start up, then describes how it works. After that is
the sanitation section, followed by service diagnosis
and repair.
TABLE OF CONTENTS
Specifications . . . . . . . . . . . . . . . . . PAGE 2
Air Cooled Layout . . . . . . . . . . . . . . . PAGE 3
Water Cooled Layout . . . . . . . . . . . . . PAGE 4
Pre-Installation . . . . . . . . . . . . . . . . . PAGE 5
Location & Assembly . . . . . . . . . . . . . PAGE 6
Stacking . . . . . . . . . . . . . . . . . . . . PAGE 7
Stacking . . . . . . . . . . . . . . . . . . . . PAGE 8
Bin Control: Installation . . . . . . . . . . . . PAGE 9
Bin Control . . . . . . . . . . . . . . . . . . . PAGE 10
Plumbing . . . . . . . . . . . . . . . . . . . . PAGE 11
Electrical . . . . . . . . . . . . . . . . . . . . PAGE 12
After Utility Connections . . . . . . . . . . . . PAGE 13
Component Description and Function . . . . . PAGE 14
System Controller . . . . . . . . . . . . . . . PAGE 15
Initial Start Up . . . . . . . . . . . . . . . . . PAGE 16
Adjustments . . . . . . . . . . . . . . . . . . PAGE 17
Adjustments . . . . . . . . . . . . . . . . . . PAGE 18
How To Operate The System Controller . . . PAGE 19
How The Electronic Cuber Works . . . . . . . PAGE 20
How The Electronic Cuber Works . . . . . . . PAGE 21
Technicians Only: Freeze Cycle Operational
Sequence . . . . . . . . . . . . . . . . . . . PAGE 22
Technicians Only: Harvest Cycle Operational
Sequence . . . . . . . . . . . . . . . . . . . PAGE 23
Sanitation and Cleaning . . . . . . . . . . . . PAGE 24
Additional Maintenance . . . . . . . . . . . . PAGE 25
Additional Maintenance: Water Distributors . . PAGE 26
Additional Maintenance: Inlet Water Valve
Screen . . . . . . . . . . . . . . . . . . . . . PAGE 27
Additional Maintenance: Ice Sensors, Condenser
. . . . . . . . . . . . . . . . . . . . . . . . PAGE 28
Service Diagnosis: Controller Diagnostic Light
Analysis . . . . . . . . . . . . . . . . . . . . PAGE 29
Service Diagnosis . . . . . . . . . . . . . . . PAGE 30
Service Diagnosis: Components . . . . . . . PAGE 31
PTCR . . . . . . . . . . . . . . . . . . . . . PAGE 32
Operational Characteristics: CME1356 . . . . PAGE 33
Operational Characteristics: CME1656 . . . . PAGE 34
Removal and Replacement . . . . . . . . . . PAGE 36
Removal and Replacement: System Controller PAGE 37
Removal and Replacement: Water Level Sensor
. . . . . . . . . . . . . . . . . . . . . . . . PAGE 37
Removal and Replacement: Fan Blade and/or Fan
Motor
. . . . . . . . . . . . . . . . . . . . . PAGE 38
Access Valves . . . . . . . . . . . . . . . . . PAGE 39
Liquid Charging . . . . . . . . . . . . . . . . PAGE 40
Before Calling for Service . . . . . . . . . . . PAGE 41
Parts Lists and Wiring Diagrams are Located in the Center of this Manual
CME1356 and CME1656
May 2000
Page 1