Prochem Legend SE AD - Manual (Page 15)

INSTALLATION
LEGEND SE 980059 06/19/03 3-7
WASTE TANK TO CONSOLE
CONNECTION
NOTE: Before connecting any hoses to the waste
tanks, make certain the hose clamps are on each
hose.
1. See Figure 11. Connect the 12” long section of
2” I.D. internal vac hose to the 2” dia. vac inlet
tube on the console and the 2” dia. inlet tube on
the waste tank. Tighten the hose clamps.
2. Connect the 25” long section of 2-7/8" I.D.
internal vac hose to the 2-7/8” dia. vac outlet
tube on the waste tank and to the vacuum pump
relief valve on the console. It may be necessary
to cut this hose to fit. Tighten the hose clamps.
3. Connect the 2” I.D. waste removal hose to the 2”
dia. tube at the bottom of the waste tank.
Tighten the hose clamps.
4. Connect the 5/16" I.D. water box hose to the
barb fitting (pointed downward) on the waste
tank, which is mounted on the outside of the
waste tank. Tighten the hose clamps.
5. Connect the console engine shut-off cord to the
waste tank level sensor cord.
BATTERY CONNECTION
Dangerous Acid, Explosive Gases!
Batteries contain sulfuric acid. To prevent acid
burns, avoid contact with skin, eyes, and
clothing. Batteries produce explosive hydrogen
gas while being charged. To prevent a fire or
explosion, charge batteries only in well-
ventilated areas. Keep sparks, open flames, and
other sources of ignition away from the battery
at all times. Keep batteries out of the reach of
children. Remove all jewelry when servicing
batteries.
Before disconnecting the negative (-) ground
cable, make sure all switches are OFF. If ON, a
spark will occur at the ground cable terminal
which could cause an explosion if hydrogen gas
or gasoline vapors are present. When
disconnecting the battery, ALWAYS disconnect
the negative (-) terminal FIRST.
1. Attach the red positive (+) battery cable from the
console starter solenoid to the positive (+)
terminal on the battery and tighten the holding
nut.
2. Next, attach the black negative (-) battery cable
from the console ground to the negative (-)
terminal on the battery and tighten the holding
nut.
FIRE EXTINGUISHER
We recommend that a fire extinguisher, preferably
rated for A, B, & C type fires, be installed inside the
vehicle.
FROM
STARTER
SOLENOID
ON CONSOLE
FROM
GROUND
CONNECTION
ON CONSOLE
+
-
BATTERY
WASTE
TANK
BATTERY HOOK-UP