JLG 1100S Service Manual - Manual (Page 374)

SECTION 6 - JLG CONTROL SYSTEM
6-100 – JLG Lift – 3121256
850 85 0 <<< MOMENT / LOAD PINS >>>
851 85 1 MOMENT PIN - HORIZONTAL FORCE OUT OF RANGE The Moment Pin horizontal
force is out of range.
852 85 2 MOMENT PIN - VERTICAL FORCE OUT OF RANGE The Moment Pin vertical
force is out of range.
853 85 3 LOAD PIN - HORIZONTAL FORCE OUT OF RANGE The Load Pin horizontal
force is out of range. -1250
854 85 4 LOAD PIN - VERTICAL FORCE OUT OF RANGE The Load Pin vertical force
is out of range. -1250
855 85 5 MOMENT PIN - SENSOR FAULT The Moment Pin has
reported a fault.
856 85 6 LOAD PIN - SENSOR FAULT The Load Pin has reported
a fault. -1250
857 85 7 NEW MOMENT PIN DETECTED A new Moment Pin has
been detected.
858 85 8 NEW LOAD PIN DETECTED A new Load Pin has been
detected. -1250
859 85 9 LOAD PIN/TOWER LIFT CYLINDER ANGLE DISAGREE-
MENT There is a disagreement
between the Load Pin and
the Tower Lift cylinder
Angle. -1250
8510 85 10 LOAD PIN - FORCE VALUES NOT CHANGING The Load Pin is not chang-
ing. -1250
8511 85 11 LOAD PIN - FORCE TOO LOW OVER TOWER ANGLE
CHANGE X -1250
8512 85 12 LOAD PIN - FORCE TOO LOW OVER MAIN ANGLE
CHANGE X -1250
8513 85 13 LOAD PIN - FORCE TOO LOW OVER MAIN LENGTH TRAN-
SITION X -1250
860 86 0 <<< STEERING / AXLE >>>
861 86 1 RESTRICTED TO TRANSPORT - OSCILLATING AXLE
PRESSURE SWITCH DISAGREEMENT The Oscillating Axle Pres-
sure Switch indicates pres-
sure while not driving or
does not indicate pressure
while driving and restricted
to transport. - Electrically released Oscil-
lated Axles equipped vehi-
cles only.
862 86 2 AXLE EXTEND VALVE - SHORT TO BATTERY OR OPEN
CIRCUIT There is a Short to Battery
or an Open Circuit to the
Axle Extend Valve.
863 86 3 AXLE EXTEND VALVE - SHORT TO GROUND There is a Short to Ground
to the Axle Extend Valve.
864 86 4 AXLE RETRACT VALVE - SHORT TO BATTERY OR OPEN
CIRCUIT There is a Short to Battery
or an Open Circuit to the
Axle Retract Valve.
865 86 5 AXLE RETRACT VALVE - SHORT TO GROUND There is a Short to Ground
to the Axle Retract Valve.
Table 6-6. Diagnostic Trouble Code Chart
DTC
Flash
Code
Sequence Fault Message Fault Description Check