Multiquip WRS5200 (ORIGINAL COPY) - Manual (Page 10)

page 10 — wrs5200 hydraulic roller screed • operaTion manual — rev. #0 (10/22/10)
SafetY infOrMatiOn
screed safeTy
danger
„ Engine fuel exhaust gases contain poisonous carbon
monoxide. This gas is colorless and odorless, and can
cause death if inhaled.
„ The engine of this equipment requires an adequate free
fl ow of cooling air. never operate this equipment in any
enclosed or narrow area
where free fl ow of the air is
restricted. If the air fl ow is
restricted it will cause injury
to people and property and
serious damage to the
equipment or engine.
„ never operate the equipment in an explosive
atmosphere or near combustible materials. An
explosion or fi re could result causing severe
bodily harm or even death.
warning
„ If applicable, never use your hand to fi nd
hydraulic leaks. Use a piece of wood or
cardboard. Hydraulic fl uid injected into the
skin must be treated by a knowledgable
physician immediately or severe injury or
death can occur.
„ always keep clear of rotating or moving
parts while operating the screed.
„ never disconnect any emergency or safety devices.
These devices are intended for operator safety.
Disconnection of these devices can cause severe injury,
bodily harm or even death. Disconnection of any of these
devices will void all warranties.
cauTion
„ never allow passengers or riders on the screed during
operation.
„ never lubricate components or attempt service on a
running machine.
„ never place your feet or hands between the rollers
while starting or operating this equipment.
DANGEROUS
GAS FUMES
19
20
NOTICE
„ always keep the machine in proper running condition.
„ Fix damage to machine and replace any broken parts
immediately.
„ always store equipment properly when it is not being
used. Equipment should be stored in a clean, dry location
out of the reach of children and unauthorized personnel.
engine safeTy
warning
„ do noT place hands or fingers inside engine
compartment when engine is running.
„ never operate the engine with heat shields or
guards removed.
„ Keep fi ngers, hands hair and clothing away
from all moving parts to prevent injury.
„ do noT remove the radiator cap while the
engine is hot. High pressure boiling water will gush out
of the radiator and severely scald any persons in the
general area of the screed.
„ do noT remove the coolant drain plug
while the engine is hot. Hot coolant will
gush out of the coolant tank and severely
scald any persons in the general area of
the screed.
„ do noT remove the engine oil drain plug while the
engine is hot. Hot oil will gush out of the oil tank and
severely scald any persons in the general area of the
screed.
cauTion
„ never touch the hot exhaust manifold,
muffl er or cylinder. Allow these parts to cool
before servicing equipment.