Snorkel A38E-sn006001+ - Manual (Page 23)

Operation
Section
3-3 A38E Work Platform
3.1
3.1 Safety Rules and Precautions
Before using the A38E Work Platform it is
imperative to read, understand and follow the
following Safety Rules and Precautions.
NEVER operate the machine unless you have been
fully trained in its safe use, are medically fit and have
read and fully understood these instructions.
NEVER leave the A38E unattended with the Platform
in the raised position.
ALWAYS position the machine on firm level ground
with a minimum bearing capacity of 78 kg /cm 2
(1109 psi).
CHECK that no overhead obstructions exist within
the machines range of movement.
DO NOT work within 3 metres (10 feet) of live
overhead cables. Set up warning tape barrier at the
safe distance.
(THIS MACHINE IS NOT INSULATED).
DO NOT exceed the safe working load of 215 kg,
CE=max. 1 persons Outdoor + Tools 135Kg
2 person Indoor + Tools 55Kg
See specification table on page 1-3 .
NEVER sit, stand or climb on guard rail or midrail of
the platform.
NEVER use ladders or scaffolding on the platform.
DO NOT use the machine as a crane or for any other
application involving additional loads or forces. The
maximum side force must not exceed 200N
Outdoors / 400N Indoors, (ANSI = 90 ft. lbs).
DO NOT increase wind loadings by fitting items such
as sign boards, flags etc. to the cage or boom.
DISTRIBUTE all loads evenly on the platform. See
Table 1-1 for maximum platform load.
NEVER use damaged equipment. (Contact Snorkel
Ltd. for instructions).
NEVER attach overhanging loads or increase the
size of the working platform.
DO NOT use in winds exceeding 12.5 m/s (28 mph -
Beaufort Force 6)
NEVER change or modify operating or safety
systems.
INSPECT the machine thoroughly for cracked welds,
loose hardware, hydraulic leaks, damaged control
cable, loose wire connections and wheel bolts.
NEVER climb down an elevating assembly with
platform elevated.
NEVER perform service on or in the elevating
assembly while the platform is elevated without first
blocking the elevating assembly.
NEVER recharge batteries near sparks or open
flame; batteries under charge emit highly explosive
hydrogen gas.
SECURE the work platform against unauthorised use
by turning Keyswitch off and removing key from
switch.
NEVER replace any component or part with anything
other than original Snorkel replacement parts without
Snorkel’s consent.
NEVER leave the machine unattended while the
Gearbox Drive is disengaged.
(ANSI 475 lbs)
(ANSI=max. 2 person Indoor/Outdoor)
WARNING