Snorkel AB46J User Manual
Snorkel Special machinery
Table of contents
Document Outline
- Table of Contents
- Electrical Hazard
- Introduction
- 1. Safety
- 2. Safety Devices
- Safety device information 2-1
- Emergency Power Battery 2-1
- Emergency stop switches 2-1
- Flashing Lights 2-2
- Platform Foot Switch 2-2
- GFCI (Ground Fault Circuit Interrupt) 2-2
- Platform Gravity Gate 2-2
- Ground Operation Switch 2-3
- Platform Guardrails 2-3
- Operator Horn 2-3
- Lanyard Anchor Points 2-3
- Level Sensor 2-4
- Motion Warning Alarm 2-4
- Platform Swinging Gate 2-4
- Tilt Alarm 2-4
- Safety device information 2-1
- 3. Specifications
- 4. Gauges, Circuit Breakers and Displays
- 5. Batteries and Battery Charging
- 6. Controls
- 7. Daily Inspection and Maintenance
- Daily Inspection and Maintenance Table 7-1
- Wiring harnesses 7-2
- Battery terminals 7-2
- Battery fluid level 7-3
- Hydraulic oil 7-3
- Hydraulic oil leaks 7-3
- Tires 7-3
- Bolts and fasteners 7-4
- Structural damage and welds 7-5
- Lanyard anchor points 7-5
- Platform guardrails 7-5
- Platform gravity gate 7-6
- Platform swinging gate 7-6
- Flashing lights 7-6
- Battery charger 7-6
- Ground control box 7-7
- Level sensor 7-7
- Platform control box 7-7
- Emergency power 7-8
- GFCI (Ground Fault Circuit Interrupt) 7-8
- Slide pads 7-9
- Hydraulic oil filter 7-9
- Placards and decals 7-10
- 8. Operation
- 9. Emergency Operation
- 10. Stowing and Transporting
- 11. Options
- 12. Fire Fighting and Chemical Containment
- 13. Operator's Troubleshooting
- Index
- !
- A
- B
- C
- California Proposition 65 warning
- Chemical Containment, 12-1, 12-2
- Circuit Breaker
- Control Stations, 8-1
- Controls
- Control switches
- Battery switch, 5-2, 6-9, 7-6, 7-9, 8-2, 9-1, 9-2, 10-1, 10-3, 11-1
- Boom Speed, 6-2, 6-4, 8-2, 8-3
- Drive Range, 6-4, 8-3, 10-2
- Emergency power, 7-8
- Emergency Power, 6-2, 6-4, 9-1, 9-2
- Emergency Stop, 6-1, 6-2, 6-4, 7-7, 7-9, 8-1, 8-2, 8-3, 9-1, 11-1
- Emergency Stop , 9-2
- Extend/Retract, 6-2, 6-4
- Ground Operation, 6-2, 7-7, 7-9, 8-4, 9-2
- Horn, 6-4, 7-7
- Jib, 6-2, 6-4
- Main Boom Lift, 6-2, 6-4
- Master Key Switch, 6-2, 7-1, 7-7, 7-9, 8-2, 8-3, 9-1, 9-2, 10-1, 10-2, 11-1
- Platform Level, 6-2, 6-4, 10-2
- Platform Rotate, 6-2, 6-4
- Platform/Ground Selector, 6-2, 7-9, 8-2, 8-3, 9-1, 9-2
- Riser Lift, 6-2, 6-4, 7-7, 7-9
- Swing, 6-2, 6-4, 7-7, 7-8, 10-2
- Drive/Steer controller, 8-6, 10-2
- Drive/Steer Controller, 6-4, 8-5
- Ground Control Box, 6-2
- Platform control box, 8-6
- platform foot switch, 6-9
- Control switches
- Controls and Control Decals Locations, 6-1
- Controls Description, 6-1
- Cowling door, 7-9, 10-3
- Crushing, 1-2
- D
- E
- F
- G
- H
- I
- Inspection
- Operators daily inspection, 7-1
- Battery charger, 7-6
- battery fluid level, 7-3
- battery terminals, 7-2
- bolts and fasteners, 7-4
- Emergency power, 7-8
- GFCI (Ground Fault Circuit Interrupt), 7-8
- Ground control box, 7-7
- hydraulic oil, 7-3
- hydraulic oil filter, 7-9
- hydraulic oil leaks, 7-3
- Inspection and Maintenance Table, 7-1
- lanyard anchor points, 7-5
- level sensor, 7-7
- Platform control box, 7-7
- platform gravity gate, 7-6
- platform guardrails, 7-5
- platform swinging gate, 7-6
- slide pads, 7-9
- structural damage and welds, 7-5
- tires, 7-3
- wiring harnesses, 7-2
- Pre-start, 1-1
- Operators daily inspection, 7-1
- Inspection
- L
- M
- N
- O
- Operating Precautions, 1-3
- Operating Procedures, 8-1
- Operation, 8-1
- Operator General Precautions, 1-2
- Operator Horn, 2-3
- Operator Maintenance Precautions, 1-3
- Operators
- Options
- OSHA, ANSI and CSA Standards
- Overall dimensions, 3-2
- P
- Q
- R
- S
- Safe Operation, 1-1
- Safety
- devices, 2-1
- emergency power battery, 2-1
- Emergency Stop button, 2-1
- fall restraint, 8-3
- flashing lights, 2-2
- ground fault circuit interrupt, 2-2
- Ground Operation switch, 2-3
- lanyard anchor points, 2-3
- level sensor , 2-4
- motion warning alarm , 2-4
- operator horn, 2-3
- platform foot switch, 2-2
- platform gravity gate, 2-2
- platform guardrails , 2-3
- platform swinging gate, 2-4
- Operator General Precautions
- personnel, 1-1
- rules, 1-1
- safe operation, 1-1
- devices, 2-1
- Safety Decals and Placards, 1-3
- Sandblast protection kit, 8-1
- Securing for Day, 8-6
- Signs, Caution, Danger, Notes
- Slide pads, 7-9
- Starting and Stopping Precautions, 1-3
- Starting From Ground Control Box, 8-2
- Starting From Platform Control Box, 8-2
- Steering, 8-6
- Stowing, 10-1
- Structural damage and welds, 7-5
- T
- U
- W