Rice Lake IQ Plus 355 Installation Manual V1.17 - Manual (Page 12)

8 IQ plus 355 Installation Manual
2.7 Replacement Parts
Table 2-4 lists replacement parts for the IQ plus 355, including all parts referenced in Figures 2-5 through 2-9.
Ref
Number PN Description (Quantity) Figure
1 14626 Kep nuts, 8-32NC hex (3) Figure 2-5 on page 9, Figure 2-8 on page 11
2 52211 Display and CPU board assembly, 115 VAC (1) Figure 2-6 on page 10
52210 Display and CPU board assembly, 230 VAC (1)
3 15365 Board mounting spacers (4)
4 39017 Enclosure backplate (1) Figure 2-5 on page 9
5 15626 Cable grips, PG9 (3)
6 30375 Nylon seal rings for cable grips (3)
7 15627 Locknuts, PCN9 (3)
8 19538 Cable grip plugs (2)
9 45042* Sealing washers (4)
10 44676 Sealing washer for setup switch access screw (1)
11 42640 Setup switch access screw, 1/4 x 28NF x 1/4 (1)
12 41965 Power cord assembly, 115VAC (1) Figure 2-5 on page 9, Figure 2-7 on page 11
45254 Power cord assembly, 230VAC (1)
13 41964 Line filter assembly (1) Figure 2-7 on page 11
14 14621 Kep nuts, 6-32NC hex (4) Figure 2-6 on page 10
16 68403 Four-cornered wing knobs for tilt stand (2) Figure 2-5 on page 9
30342 Two-cornered wing knobs for tilt stand (2)
17 29635 Tilt stand (1)
18 15144 Nylon washers for tilt stand, 1/4x1x1/16 (2)
20 15134 Lock washers, internal tooth, No. 8 , Type A (4)
22 50556 Overlay membrane panel (1) Figure 2-9 on page 11
23 50555 Enclosure (1)
24 14862* Screws, 8-32C x 3/8 (4) Figure 2-5 on page 9
26 45043 Ground wire, 4-in., No. 8 (1)
27 39037 Backplate gasket (1) Figure 2-5 on page 9
28 51974 Setup switch assembly (1) Figure 2-7 on page 11
29 16892 Ground/Earth Label (1)
30 15650* Cable tie mounts (8) Figure 2-6 on page 10
31 45302 Line filter standoffs (2) Figure 2-7 on page 11
33 15131 Lock washers, external tooth, No. 6, Type A (8) Figure 2-6 on page 10
— 70600 7-position connectors for J4, and J12 (2) Figure 2-3 on page 5
— 70599 6-position connectors for J1 (1)
— 53848 200 mA TR5 subminiature fuses (2), 115 VAC F1 and F2 in Figure 2-3 on page 5
(See Caution below)
53881 100 mA TR5 subminiature fuses (2), 230 VAC
* Additional parts included in parts kit.
For protection against risk of fire, replace fuses only with same type and rating fuse.
See Section 7.11 on page 46 for complete fuse specifications.
Table 2-4. Replacement Parts
Caution