JLG 40RTS ANSI Parts Manual - Manual (Page 78)

2-28 3120692
SECTION 2 GROUND COMPONENTS
S
E
C
T
I
O
N
2
G
R
O
U
N
D
C
O
M
P
O
N
E
N
T
S
127 0630360 Bolt, Carriage 5/16"-18NC x 1 1/4" 1
128 4711500 Flatwasher 5/16" Narrow 5
129 3311501 Nut 5/16"-18NC 5
130 0641508 Bolt 5/16"-18NC x 1" 1
131 4761500 Lockwasher 5/16" 2
132 0641610 Bolt 3/8"-16NC x 1 1/4" 6
133 4751600 Flatwasher 3/8" 15
134 4060713 Shield 1
135 3536151 Guard, Exhaust 1
136 1320022 Clamp 2
137 2720058 Hose, Fuel Line 6 ft./1.8m
138 3921008 Bolt #10-24NC x 1/2" 3
139 Not Used
140 0400075 Battery 1
141 3980007 Masonite 1
142 1060254 Cable, Battery (Battery + to Starter Solenoid) 1
143 3300029 Wingnut 3/8"-16NC 2
144 1670841 Cover, Battery 1
145 1060360 Cable, Battery (Battery Neg to Ground) 1
146 0630370 Rod, Tie-Down 2
147 0400174 Tie-Down, Battery 1
148 3620027 Radiator 1
149 Not Used
150 1320020 U-Clamp 1 1/2" 1
151 1320026 U-Clamp 1 3/4" 1
152 3252356 Nameplate - Important (LP Only) (S/N 71528 to Pres-
ent) (Not Shown Located Inside of Lower Access
Door) 1
153 1703162 Decal - Fan Blade (S/N 71528 to Present)
(Not Shown Located on Radiator Shield) 2
154 0840046 Boot, Battery (Positive) (Not Shown) 1
155 0840047 Boot, Battery (Negative) (Not Shown) 1
PUMP COUPLING INSTALLATION Ref.
201 7016661 Pump Coupling 1
202 0080163 Adapter, Pump Mounting 1
203 0700808 Bolt, Metric 8mm 1.25 x 16mm 6
204 4831900 Lockwasher, Metric 8mm 6
205 0641610 Bolt 3/8"-16NC x 1 1/4" 8
206 4761600 Lockwasher 3/8" 8
207 3020021 Grease, Coupling (Not Shown) A/R
Note: Coupling Spline must be greased with lithium
soap based grease prior to installation. Ref.
FIGURE 2-6. ENGINE INSTALLATION - FORD VSG-413 (CONTINUED)
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.