JLG 40RTS ANSI Parts Manual - Manual (Page 137)

3120692 4-13
S
E
C
T
I
O
N
4
P
L
A
T
F
O
R
M
SECTION 4 PLATFORM
FIGURE 4-4. PLATFORM CONSOLE BOX INSTALLATION
FIG & ITEM # PART NUMBER DESCRIPTION QTY. REV.
0253701 CONSOLE BOX INSTALLATION Ref. 14
Note: See Section 10 for Non-Standard Console
Boxes. Ref.
1 Box, Control Options: 1
0860799 Prior to S/N 80670
0861377 S/N 80670 to Present
2 Nameplate, Lid 1
Use 3252310 Prior to July 1993 (was p/n 3252229)
3252310 July 1993 to S/N 57701 (was p/n 3252310)
3252620 S/N 57701 to Present
3 4420008 Tape, Insulation 38in/96.5cm
4 Bracket, Hanger 2
0901897 Prior to S/N46418
0902456 S/N46418 to S/N 57701
4845938 S/N 57701 to Present
5 0641404 Bolt 1/4"-20NC x 1/2" A/R
6 4791400 Starwasher 1/4" A/R
7 1060380 Lanyard - 10" (Prior to S/N46418 Only) 1
8 3760170 Ring (Prior to S/N46418 Only) 1
3421453 Pin, Snap (Prior to S/N46418 Only) 1
9 2560141 Thumbscrew (S/N46418 to Present Only) 1
0181847 Angle (S/N46418 to Present Only) 1
10 3520082 Plug, Hole 1
11 4460470 Nut, Conduit 1
12 4460471 Lockwasher, Conduit 1
13 4460463 Receptacle 1
14 4360339 Switch, Push Button (Enable) 1
7012593 Cap, Rubber 1
15 4360267 Block, Contact - N.O. 1
16 0100035 Loctite #222 A/R
17 Circuit Card Assembly 1
Use 0610114 Prior to February 1995 (was p/n 0610103)
0610114 February 1995 to S/N 57701
7012658 Fuse - 7.5 Amp 1
0610110 Bracket Replacement Kit 1
0902514 Bracket, Relay (S/N 57701 to Present) 1
18 Nut Options: 2
3310601 Nut #6-32NC (Prior to S/N 57701)
3311001 Nut #10-24NC (S/N 57701 to Present)
19 Lockwasher Options: A/R
4770600 Lockwasher #6 (Prior to S/N 57701) 2
4761000 Lockwasher #10 (S/N 57701 to Present) 4
20 3900177 Screw, Machine #8 x 1/2" 8
21 Controller, PQ Options: (Drive/Steer) 1
1600157 Prior to S/N 57701 (See Figure 4-5 for
Breakdown)
1600290 S/N 57701 to Present (See Figure 4-6 for
Breakdown)