Kohler Aegis TP-2509 - Manual (Page 7)

1.5
Section 1
Safety and General Information
1
Fuel Type
For best results, use only clean, fresh, unleaded
gasoline with a pump sticker octane rating of 87 or
higher. In countries using the Research method, it
should be 90 octane minimum.
Unleaded gasoline is recommended, as it leaves fewer
combustion chamber deposits. Leaded gasoline may
be used in areas where unleaded is not available and
exhaust emissions are not regulated. Be aware,
however, that the cylinder head will require more
frequent service.
Gasoline/Alcohol blends
Gasohol (up to 10% ethyl alcohol, 90% unleaded
gasoline by volume) is approved as a fuel for Kohler
engines. Other gasoline/alcohol blends are not
approved.
Gasoline/Ether blends
Methyl Tertiary Butyl Ether (MTBE) and unleaded
gasoline blends (up to a maximum of 15% MTBE by
volume) are approved as a fuel for Kohler engines.
Other gasoline/ether blends are not approved.
Periodic Maintenance
WARNING: Accidental Starts!
Disabling engine. Accidental starting can cause severe injury or death. Before working on the engine or
equipment, disable the engine as follows: 1) Disconnect the spark plug lead(s). 2) Disconnect negative (-) battery
cable from battery.
Maintenance Schedule
These required maintenance procedures should be performed at the frequency stated in the table.
They should also be included as part of any seasonal tune-up.
1 Perform these maintenance procedures more frequently under extremely dusty, dirty conditions.
2 Only required for Denso starters. Not necessary on Delco starters. Have a Kohler Engine Service Dealer perform
this service.
Refer to:
Section 5
Section 6
Section 7
Section 4
Section 4
Maintenance Required Frequency
• Fill fuel tank.
• Check oil level.
• Check coolant level.
• Check air cleaner for dirty 1 , loose, or damaged parts.
• Check air intake screen, radiator, and cooling areas,
clean as necessary
1 .
Daily or Before
Starting Engine
Section 4
Section 4
Section 7
Section 5
Section 6
Section 8
• Service precleaner element 1 .
• Replace air cleaner element 1 .
• Clean and check cooling areas.
• Replace fuel filter.
Every 25 Hours
Every 100 Hours
Annually or
Every 200 Hours
• Change oil and oil filter (more frequently under severe
conditions).
• Check spark plug condition and gap.
Section 8
Section 8 • Have solenoid shift starter disassembled and cleaned 2 .
• Replace spark plugs.
• Change engine coolant.
Annually or
Every 500 Hours
Every 2 Years or
Every 1000 Hours
Section 7