Caution – MacDon Double Windrow Attachment User Manual
Page 61

SECTION OM – OPERATOR’S MANUAL
Form # 169365
OM-37
Issue – May 2008
4.5 MAINTENANCE
SCHEDULE
The following maintenance schedule is a listing of
periodic maintenance procedures, organized by
service intervals. Regular maintenance is the best
insurance against early wear and untimely
breakdowns. Following this schedule will increase
machine life. For detailed instructions, refer to the
specific headings in this manual. Use the lubricant
specified in Paragraph 4.2.1, Lubricants.
Service Intervals: The recommended service
intervals are in hours of operation. Where a
service interval is given in more than one time
frame, e.g. "3 Months or 3000 Miles", service the
machine at whichever interval is reached first.
IMPORTANT
Recommended intervals are for average
conditions. Service the machine more
often if operated under adverse
conditions (severe dust, extra heavy
loads, etc.).
CAUTION
Carefully follow safety messages given
under Paragraph 4.1 Recommended
Safety Procedures.
INTERVAL SERVICE
FIRST USE
Refer To Paragraph 3.3 FIRST USE.
EVERY USE
1. Check brakes operational.
2. Check breakaway system battery and switch operation.
WEEKLY
Check tire inflation pressure – 65 psi (448 kPa).
END OF
SEASON
Refer To Paragraph 3.14 STORAGE.
3 MONTHS OR
3000 MILES
(4830 km)
1. Adjust brakes to proper operating clearance.
2. Check wheel nuts and adjust as required.
3. Check tires for wear, cuts, bulging, etc.
6 MONTHS OR
6000 MILES
(9660 km)
1. Check brake magnets for wear and current draw.
2. Check brake controller for correct amperage and modulation.
3. Inspect suspension for deformation, wear, and loose fasteners.
4. Visually inspect wheels for distortion, cracks, or dents.
12 MONTHS OR
12000 MILES
(19320 km)
1. Inspect brake linings for wear or contamination.
2. Inspect wiring for bare spots, fraying, etc.
3. Inspect wheel drum for abnormal wear and scoring.
4. Inspect seals for leakage. Replace if removed.
5. Visually check header support welds for cracks.
* IT IS RECOMMENDED THAT ANNUAL MAINTENANCE BE DONE PRIOR TO START OF OPERATING
SEASON.