American Dryer Corp. AD-15 Phase 7 - Manual (Page 3)

IMPORTANT
YOU MUST DISCONNECT AND LOCK OUT THE
ELECTRIC SUPPLY AND THE GAS SUPPLY OR STEAM
SUPPLY BEFORE ANY COVERS OR PANELS ARE
REMOVED FROM THE MACHINE TO ALLOW ACCESS
FOR CLEANING, ADJUSTING, INSTALLATION, OR
TESTING OF ANY EQUIPMENT PER OSHA (Occupational
Safety and Health Administration) STANDARDS.
“Caution: Label all wires prior to disconnection when
servicing controls. Wiring errors can cause improper
operation.”
«Attention: Au moment de l’entretien des commandes,
étiquetez tous les fils avant de les débrancher. Des
erreurs de câblage peuvent entraîner un fonctionnement
inadéquat et dangereux.»
CAUTION
DRYERS SHOULD NEVER BE LEFT UNATTENDED
WHILE IN OPERATION.
When discarding or storing your old clothes dryer,
REMOVE THE DOOR.
Lorsque vous entreposez ou mettez votre sécheuse au
rebut, ENLEVEZ-EN LA PORTE.
Do not allow children to play on or in the appliance.
Close supervision of children is necessary when the
appliance is used near children.
Ne laissez pas les enfants jouer dans ou sur l’appareil.
Il est important de surveiller étroitement les enfants
lorsque l’appareil est utilisé non loin d’enfants.
FOR YOUR SAFETY
DO NOT DRY MOP HEADS IN THE DRYER.
DO NOT USE DRYER IN THE PRESENCE OF DRY
CLEANING FUMES.
WARNING
UNDER NO CIRCUMSTANCES should the dryer main
door switch, lint drawer switch, or the heat circuit devices
ever be disabled.
WARNING
The dryer must never be operated with any of the
back guards, outer tops, or service panels removed.
PERSONAL INJURY OR FIRE COULD RESULT.
WARNING
DRYER MUST NEVER BE OPERATED WITHOUT THE
LINT FILTER/SCREEN IN PLACE, EVEN IF AN EXTERNAL
LINT COLLECTION SYSTEM IS USED.
IMPORTANT
PLEASE OBSERVE ALL SAFETY PRECAUTIONS
displayed on the equipment and/or specified in the
installation manual included with the dryer.
Dryer must not be installed or stored in an area where it
will be exposed to water or weather.
The wiring diagram for the dryer is located behind the
front control panel.
IMPORTANT
Dryer must be installed in a location/environment,
which the ambient temperature remains between 40°
F (4.44° C) and 130° F (54.44° C).
Table of Contents
SAFETY PRECAUTIONS ........................ 2
SPECIFICATIONS ................................... 3
INSTALLATION PROCEDURES............. 4
Unpacking/Setting Up ...................................... 4
Location Requirements ................................... 4
Dryer Enclosure Requirements ...................... 5
Fresh Air Supply Requirements ...................... 5
Exhaust Requirements ................................... 5
Electrical Information ....................................... 8
Gas Information ............................................... 12
Steam Information ........................................... 13
Preparation For Operation/Start-Up ................ 16
Preoperational Tests ....................................... 16
Preoperational Instructions ............................. 17
Shutdown Instructions ..................................... 19
SERVICE/PARTS INFORMATION .......... 19
Service .............................................................. 19
Parts ................................................................. 19
WARRANTY INFORMATION ................... 19
Returning Warranty Cards ............................... 19
Warranty ........................................................... 19
Returning Warranty Parts ................................ 19
ROUTINE MAINTENANCE ..................... 20
Cleaning ........................................................... 20
Adjustments ..................................................... 21
Lubrication ....................................................... 21
DATA LABEL INFORMATION ................. 21
PROCEDURE FOR FUNCTIONAL
CHECK OF REPLACEMENT
COMPONENTS ....................................... 22
MANUAL RESET BURNER
HI-LIMIT INSTRUCTIONS ...................... 24
Phase 7 ............................................................ 24
Dual Timer ....................................................... 24
SENSOR ACTIVATED FIRE
EXTINGUISHING (S.A.F.E.) SYSTEM .... 25