Heat & Glo Fireplace Heat & Glo Fireplace 6000C - Manual (Page 3)

Heat & Glo • 6000C, 6000C-IPI, 8000C, 8000C-IPI • 2164-900 Rev. T • 9/12 3
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Table of Contents
A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
B. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1 Listing and Code Approvals
A. Appliance Certification . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
B. Tempered Glass Specifications . . . . . . . . . . . . . . . . . . . . . 7
C. BTU Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 7
E. Non-Combustible Materials Specification. . . . . . . . . . . . . . 8
F. Combustible Materials Specification . . . . . . . . . . . . . . . . . 8
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
H. Requirements for the Commonwealth of Massachusetts . . 9
User Guide
2 Operating Instructions
A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
C. Fan Kit (optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
D. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
E. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 11
F. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
G. Remote Controls, Wall Controls and Wall Switches . . . . . 11
H. IPI Battery Tray/Battery Installation . . . . . . . . . . . . . . . . . 12
I. Control Module Operation . . . . . . . . . . . . . . . . . . . . . . . . 12
J. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 12
K. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 13
L. Lighting Instructions (Standing Pilot) . . . . . . . . . . . . . . . . 14
M. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
N. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 15
3 Maintenance and Service
A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 16
B. Maintenance Tasks-Qualified Service Technician . . . . . . 17
C. Refractory, Grate and Valve Assembly Removal . . . . . . . 18
D. Burner Identification/Verification . . . . . . . . . . . . . . . . . . . . 19
Installer Guide
4 Getting Started
A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 20
B. Design and Installation Considerations . . . . . . . . . . . . . . 21
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 21
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 21
5 Framing and Clearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 22
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 23
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 24
6 Termination Locations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 25
7 Vent Information and Diagrams
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
D. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
E. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 39
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 39
C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 40
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 41
E. Installing the Optional Heat-Zone
® Gas Kit . . . . . . . . . . . 41
9 Appliance Preparation
A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
B. Rear Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
C. Installing the Non-combustible Board. . . . . . . . . . . . . . . . 44
D. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 44
10 Installing Vent Pipe (DVP and SLP Pipe)
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . . 45
B. Assemble Vent Sections (SLP Pipe Only) . . . . . . . . . . . . 46
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 46
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 47
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 47
F. Install Decorative Ceiling Components (SLP only) . . . . . . 48
G. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 49
H. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 49
I. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 50
J. Install Decorative Wall Components (SLP only) . . . . . . . . 50
K. Heat Shield Requirements for Horizontal Termination . . . 50
L. Install Horizontal Termination Cap (DVP and SLP Pipe) . 51
11 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 52
12 Electrical Information
A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
B. IntelliFire Plus™ Ignition System Wiring . . . . . . . . . . . . . 53
C. Standing Pilot Ignition System Wiring . . . . . . . . . . . . . . . 53
D. Optional Accessories Requirements . . . . . . . . . . . . . . . . 53
E. Electrical Service and Repair . . . . . . . . . . . . . . . . . . . . . . 55