Henny Penny PRESSURE FRYERS 600 - Manual (Page 62)

Model 500/600
GLOSSARY
HENNY PENNY PRESSURE FRYERS
air valve a valve that allows air into the filter lines when the pump is on in the mixing
mode on eight head fryers
airflow switch a switch that senses the amount of airflow coming from the blower; if the airflow falls
below a certain level, the switch cuts power to the gas control valve that shuts down the
burners on eight head gas fryers
blower located on the rear of an eight head gas fryer, the blower pulls flue gases out of the flue
and provides the proper amount of air to the burner tubes for efficient combustion
breading a flour and seasoning mixture used to coat the product prior to frying
burner assembly an assembly on gas fryers that houses the pilot light which ignites the gas that heats the
(gas fryers only) fryer
burner chamber the area on four head fryers in which the gas combustion that heats the shortening takes
(gas fryers only) place
burner tubes the tubes in eight head fryers through which heated air is forced to heat the shortening
(gas fryers only)
carrier a wire frame inside the eight head frypot that holds five racks of product during the cook
cycle
casters the wheels on bottom of the fryer that allow the unit to roll; casters should be locked
when unit is in use and not being moved; casters may be adjusted to help level the fryer
cleaning solution an agent used to clean the frypot; see recommended cleaning procedures
cold zone an area in the bottom of the frypot where shortening is cooler than the area above; the
zone allows the crumbs to settle without burning
condensation drain pan a pan located at the bottom of the fryer that collects condensation from the steam exhaust
system; the pan should be removed and emptied periodically
cook cycle a programmed cycle that cooks a particular product at a preselected temperature and for a
preselected time
cooking load the amount of product cooked during a cook cycle
cool a preset temperature, usually 250° F (121° C) or less, which can be manually or
automatically switched to, to save the life of the shortening, when not cooking.
counterweight the weights shipped with the fryer that, when installed in the counterweight assembly,
enable the eight head fryer lid to lift easily
counterweight assembly an assembly of weights and cables enabling the eight head fryer lid to lift easily
cracklings the crumbs of breading that come off the product during a cook cycle
crumb catcher the part of the filter assembly on four head fryers that filters crumbs out of the shortening
before the shortening is pumped back into the frypot
G-1 203