SkyTrak 10054 Operation Manual - Manual (Page 184)

182 Model 10054 Rev 3/02
Test Procedures
To test the function of the Boom/Outrigger Interlock System perform the
“Stabil-TRAK System Test” begining on page 178 before performing the
following test.
System Test
Step 1
a. Place the vehicle with no load on a flat, level hard surface such
as blacktop or concrete.
b. Fasten your seat belt.
Step 2
a. With outriggers in the raised position and the boom in a hori-
zontal position.
b. Extend the boom. The boom should extend until the letter “E”
appears and then should STOP. If the boom extends beyond
letter “F,” fully retract the boom and have the system repaired
before using the vehicle again.
c. Attempt to frame sway the vehicle to the right and left, it should
frame sway normally.
Step 3
a. Lower both outriggers to the ground (DO NOT lift the front
wheels of the vehicle off the ground at this time).
b. With the boom still in a horizontal position extend the boom.
The Stabil-TRAK light should come ON somewhere after the
letter “E” has appeared and remain ON while the boom extends
to full extension.
c. Attempt to raise both outriggers, they should not raise. If the
outriggers raise, STOP and retract the boom and have the sys-
tem repaired before using the vehicle again.
d. If the outriggers could not be raised, attempt to lower the outrig-
gers fully until the front wheels are off the ground, the outrig-
gers should lower.
Boom/Outrigger Interlock System Test
WARNING:
DO NOT operate this vehicle unless you are in
the seat with the seat belt fastened around you. Death or serious
personal injury could result if the belt is not securely fastened.
182
Model 10054 Rev 3/02
Te stProce dures
T o test the funct ionof the Boo m/Outr igge rI nterloc kS ystem perf orm the
“S tabil- TR AK Sy ste mT est” begin ing onpag e1 78b efor epe rfor ming the
fo llo win gt es t.
Syst emT est
Step 1
a. Pla ce th ev eh ic le wit hn ol oa do na fla t, le ve lh ard su rfa ce su ch
as blac ktop or concr ete .
b. Fas ten your sea tbe lt.
Step 2
a. Wit hou trig gers in the ra ised posit ionan dthe boom in ahor i-
zontal pos ition.
b. Ex tend theboo m.T hebo oms hould ext endunti lthe lett er“ E”
appe ars and then shoul dS TO P .If the boom ex tends be yon d
lette r“ F ,” full yr etr act the boom and have thes yst emr epai re d
bef ore using th ev ehic le agai n.
c. Attem ptto frame sw ay thev ehic le to the rig hta ndle ft,it shoul d
fram es wa yn orm ally .
Step 3
a. Lo we rb oth outr igge rs tothe groun d( DONO Tl ift the fron t
wheel sof th ev ehicl eo ffth egr ound att histi me).
b. Wit hthe boom sti llin ah orizont alp ositi one xte ndt heb oom.
Th eS tabi l-T RA Kl ig ht shou ldco meON some where after the
lette r“ E” hasap peare dan dr emain ON while theboo me xtend s
toful le xten sion.
c. Attem ptt or aise both outr igger s, they shoul dno tr ais e.If the
ou trigger sr aise ,ST OP and re tra ct th eb oom and have the sy s-
tem rep aired befo re using thev ehi cle agai n.
d. Ifth eoutr igge rs could not ber aise d,atte mptto lo wer theou trig -
ger sf ully until thefr ont wheel sar eo ff the grou nd,the outrig-
gers shou ld lo we r.
Bo om/O utri gg erIn te rlock Sy ste mT est
WA RNING:
DONO Top erate this ve hicle unles sy oua re in
the seat with thes eatbel tf astene dar ound you. Death ors erio us
pers ona li nju ry coul dr esul ti ft hebe lt is not se cur ely fa ste ned .