Sears 917.25591 - Manual (Page 20)

i¥£l¥ HOURS
1. RiPLACE SPARKPLUGS
Replace Spark Plugs at the beginning of each season or
every 100 hours, whichever comas first. Gap should be set
at .030 inch (Fig. 42).
2. LUBRICATE BALL JOINTS
a Move Rubber Soots to expose Bali Joints on Tie Rods
and Steering Link (Fig, 43K
b. Coat Bail Joirrts with Silicone Spray Lubricant.
c. Reposition Rubber Boots.
E¥i«¥
HOURS
1, REPLACE AIR CLEANER PAPER CARTRIDGE
Refer to page 18.
Linas at Fuel Filter
2. REPLACE IN-LINE FUEL FILTER
a. Remove Hose Clamps from Fuel
(Fig. 44).
b. Remove Fuel Filter.
c. Place new Fuel Filter in position with fuel line (arrow on
side of Filter in direction of Fuel Filter) and reinstall
Hose Clamps.
FIGURE 42
A BE SURE THERE ARE NO FUEL LINE
LEAKS AND THAT HOSE CLAMPS ARE
PROPERLY INSTALLED,
E¥ER¥ HOURS
FIGURE 43
1, CHANGE TRANSAXLE OIL
a. Block up Rear Axle (Fig. 45} securely or use a Tractor-
Jack. Remove left Rear Wheel by removing Hub Bolts.
b. Drain Transaxle Oil by removing Drain and Filler Plugs
(Fig's. 45 & 47) and catching Oil in suitable container.
Replace Drain Plug,
c. Refill Transaxle with S.A.E. 30 (SC, SD or SE) Motor
Oil. Capacity is 6 quarts. Pressure Relief Valve (R.H, side
of Transaxle) (Fig. 4S - Inset) may be held open to
allow Transaxie to fill more quickly.
d. Check Pressure Relief Valve. It should spring completely
closed when pulled out by hand and released.
e. Reposition wheel. Secure with Hub Bolts.
-20-
LH. SIDE
FIGURE 45