JLG 450A_AJ Series II Parts Manual - Manual (Page 159)

SECTION 2 - TURNTABLE
3121243 450A Series II/450AJ Series II 159
FIGURE 2-15. BELGIUM BUILT MACHINES/DEUTZ ENGINE INSTALLATION (Prior to SN 1300000979)
ITEM PART NUMBER QTY DESCRIPTION REV
Ref DEUTZ ENGINE INSTALLATION
Ref 4WD Machines Options:
Ref Belgium Built Machines (SN 1st digit is 1)
0272490 Ref Installation Engine, Deutz F3M1011F (Prior to SN
1300000353) G
0273754 Ref Installation Engine, Deutz F3M2011 TIER II (SN 1300000353
through 1300000978) B
1 0100011 AR Compound, Locking
2 0100020 AR Sealant
4 0641406 1 Bolt 1/4in-20NC x 3/4in (Prior to SN 1300000178)
5 0641610 2 Bolt 3/8in-16NC x 1-1/4in
6 0642010 1 Bolt 5/8in-11NC x 1-1/4in
7 0902443 1 Bracket, Hood Latch Mount
8 0902444 1 Bracket, Hood Support
9 1320022 5 Clamp, Fuel Line
10 1320223 1 Clamp, J-Clip 1/2in (Prior to SN 1300000178)
11 2180536 1 Fitting, Straight (Prior to SN 1300000353)
12 2220250 1 Fitting, Reducer (Prior to SN 1300000353)
13 2220313 1 Fitting, Elbow
14 2220459 1 Fitting, Elbow (Prior to SN 1300000353)
15 2220794 1 Fitting, Straight (Prior to SN 1300000353)
16 2720058 15.1
ft/4.6m
Hose
17 2720271 12
ft/3.66m
Hose
18 2750532 7 ft/2.14m Hose
19 3311405 2 Locknut 1/4in-20NC
20 3312005 1 Locknut 5/8in-11NC
21 3340958 1 Pad, Wear
22 3900254 1 Bolt, Shoulder
23 4751400 12 Flatwasher 1/4in Regular
24 4751600 6 Flatwasher 3/8in Regular
25 4752000 1 Flatwasher 5/8in Regular
26 4752200 2 Flatwasher 3/4in Regular
27 0641418 2 Bolt 1/4in-20NC x 2-1/4in
28 4641108 1 Valve, Dual Select (Use p/n 1001099391)
Ref Note: Original Equipment Valve may have been replaced
with Service Replacement Valve. Identify p/n stamped on
valve before ordering parts.
28A 7012974 1 Cartridge without Coil (4641108 Valve)
28A 7010543 1 Seal Kit - 7012974 Cartridge
28A 7012941 1 Cartridge without Coil (1001099391 Valve
7010543 1 Seal Kit - 7012974 Cartridge
28A 7012944 1 Coil
28B 7012995 1 Cartridge without Coil
28B 7012518 1 Seal Kit - 7012995 Cartridge
28B 7012943 1 Coil
29 0181727 1 Angle, Battery Tie-Down (Prior to SN 1300000238)
30 Ref Battery (Wet) options:
30 0400075 1 Battery (Wet) (Use p/n 8008750) (Prior to SN 1300000238)
30 8008750 1 Battery 60038 (SN 1300000238 through 1300000978)