Blodgett BLCM - Manual (Page 23)

21
Maintenance
Cleaning & Preventative Maintenance
DAiLY CLeAninG
Daily cleaning of your Combi oven is essential for sanita-
tion, and to ensure against operational difficulties.
Cleaning the exterior
1. The exterior of the appliance may be cleaned and
kept in good condition with a light oil. Saturate a cloth
and wipe the appliance when it is cold; wipe dry with
a clean cloth.
WARninG!!
Do noT spray the outside of the appliance
with water or clean with a water jet. Cleaning
with a water jet can impregnate chlorides into
the stainless steel, causing the onset of corro-
sion.
Cleaning the interior - 61, 101, 102 & 202 Models only
NOTE: DO NOT use corrosive cleaners not intended for
oven cleaning on your Combi oven.
Blodgett recommends the following products for cleaning
and rinsing of your Blodgett Combi oven. If you choose
to use products other than what Blodgett recommends,
please have your suppler send us the MSDS sheet on the
proposed alternate so we can ensure it meets our stan-
dards. Non approved products can cause harm to your
unit and can potentially void your warranty.
Recommended oven cleaners:
Johnson Diversey Suma Nova L-6
• Four, 1 gallon (3.78 litre) containers
Product code 57252280
• One, 5 gallon (18.9 litre) container
Product code 57252100
Recommended Rinse Aid:
Johnson Diversey Suma Maro A8.8
• Four, 1 gallon (3.78 litre) containers
Product code 57270280
• One, 5 gallon (18.9 litre) container
Product code 57270100
1. Open the oven door.
2. Use the attached spray hose, located beneath the
control, to clean the front drip tray. Water will run to
the drain in the oven cavity.
Run the CombiWash automatic cleaning cycle as fol-
lows:
NOTE: BLCM-23, BLCM-6 and BLCM-10 do not include
CombiWash. See below for cleaning instructions.
1. Check that the oven cleaner and rinse agent contain-
ers are both full.
2. Press the PROGRAM key. Turn the dial until COMBI-
WASH is displayed.
3. CombiWash features four different cleaning cycles.
Press the STAGE key to select the desired cleaning
cycle.
Cycle 1 (44 minutes)
Cycle 2 (1 hour)
Cycle 3 (1 hour, 49 minutes)
Cycle 4 (2 hours, 38 minutes)
NOTE: Use cycle 1 or 2 after steaming and roasting
at low temperatures. Use cycle 3 or 4 after
steaming and roasting at high temperatures.
4. Press the Start/Stop key to initiate the clean cycle.
5. If the cavity temperature is above 175ºF (80ºC), the
oven will automatically enter cool down. When the
cavity is below 175ºF (80ºC) the CombiWash cycle
begins.
6. The control counts down the time remaining in the
wash cycle.
7. When the wash cycle is over, the oven automatically
switches to an energy saving standby mode.
Cleaning the interior - BLCM-23, BLCM-6 & BLCM-10
Models only
1. Cool the oven cavity to 175ºF (80ºC).
2. Run the oven in Combi 2 for 15 minutes at 175ºF
(80ºC).
3. Following the directions on your oven cleaner, apply
to the oven liner, racks, etc.
4. Close the door and allow the cleaner to work for 10
minutes.
5. Run the oven in Combi 2 again for 15 minutes at
175ºF (80ºC).
6. Rinse the oven interior with the hand shower.