Spicer Drive Axles Service Manual Wheel Reduction Drive Axles (EA-50) - Manual (Page 31)

29
INST INST INST INST INSTALLA ALLA ALLA ALLA ALLATION OF DIFF-LOCK ASSEMBL TION OF DIFF-LOCK ASSEMBL TION OF DIFF-LOCK ASSEMBL TION OF DIFF-LOCK ASSEMBL TION OF DIFF-LOCK ASSEMBLY Y Y Y Y
7 7 7 7 7..... Install the two shift cylinder washers and bolts and
torque 30-40 Lb-Ft (41-54 N-m).
8. 8. 8. 8. 8. Install the threaded plug into the center of the shift
cylinder an torque 20-30 Lb-Ft (27-41 N-m).
9. 9. 9. 9. 9. Thread the electric switch unit into the top of the
carrier and torque 20-30 Lb-Ft (27-41 N-m).
1 1 1 1 10. 0. 0. 0. 0. Install the air coupler into the air port.
1. 1. 1. 1. 1. Place the arms of the shift fork over the clutch collar
so that the threaded end of the fork faces the
direction shown in FFFFFigur
igur igur igur igure 1 e 1 e 1 e 1 e 15 5 5 5 5.
2. 2. 2. 2. 2. Position the shift fork collar assembly into the
carrier so the collar fits over the splined differential
case.
3. 3. 3. 3. 3. While holding the collar in place insert the spring
into the shift shaft and thread the shaft into the
shift fork. Torque the shift shaft 20-30 Lb-Ft
(27-41 N-m).
4. 4. 4. 4. 4. Lubricate the O-ring of the shift piston and install
into the shift cylinder. (Install the piston so that the
metal spacer is visible. This area will fit over the
shift shaft.)
5. 5. 5. 5. 5. Clean the mating surfaces of the carrier shift
cylinder and apply a .125 in. (3.175 mm) continuous
bead of Loctite 518 to the carrier surface. See
See See See See
FFFFFigur igur igur igur igure 1 e 1 e 1 e 1 e 16. 6. 6. 6. 6.
6. 6. 6. 6. 6. Install the shift cylinder into the carrier. Do not
allow the cylinder to rotate once it has been seated.
Diff Diff Diff Diff Diff-Lock Inst -Lock Inst -Lock Inst -Lock Inst -Lock Installation Complet allation Complet allation Complet allation Complet allation Completeeeee
Loctit Loctit Loctit Loctit Loctite 5 e 5 e 5 e 5 e 51 1 1 1 18 8 8 8 8
Ga Ga Ga Ga Gask sk sk sk sket Eliminat et Eliminat et Eliminat et Eliminat et Eliminator or or or or
FFFFFigur igur igur igur igure 1 e 1 e 1 e 1 e 16 6 6 6 6