AEC FSS Series 1.5- 10 HP Fountain Solution Systems - Manual (Page 16)

FSS Series Fountain Solution Systems Page 15
IAE-600
Figure 3
FSS Series 5 hp Circulator
Fountain Solution System with Integral Water-Cooled Condenser
Model / Part Number FSS-5WG Nameplate Amps (460/3/60)
Voltage 460/3/60 Compressor 10
Leaving Fountain Solution Temp 55ºF Standard 2 hp pump 3.4
Cooling Capacity c 5-tons [(60,000 Btu/hr) (15,120 K-cal/hr) (17.6 kW)] Standard Total 13.4
Nominal Fountain Solution Flow 23 GPM
Nominal Fountain Solution Pressure 43 PSI
Condenser Water Flow 15 GPM at 85 ºF 3-hp process pump 4.8
Temperature Display Fahrenheit
Installation Site Elevation Sea level
Length 32 Inches
Width 63 Inches
Dimensions
Height 79 Inches
Standard Connected Power 20 amps
Shipping Weight pounds
Operating Weight pounds
Process Connections 1 inch hose barb
Condenser Connections 1 inch hose barb
Water Make-up 1 inch hose barb
Overflow 1 inch hose barb
Internal Tank Drain ½ inch hose barb
Etch/Additive Connections 3/8 inch tube
Air Connections 3/8 inch tube
c Cooling capacity based on operation with 55°F leaving fountain solution temperature, 85°F condenser water, standard pump, 60
hertz operation and operation sea level.
ELECTRICAL
ENCLOSURE
FRONT VIEW
9"
17"
DRAIN
SIDE VIEW
5"
15"
TO PROCESS
FROM PROCESS
WATER IN
OVER
FLOW
CONDENSER IN
CONDENSER OUT
BACK VIEW
ETCH
ADDITIVE
AIR OUT
AIR IN
21"
26"
30"
9"
6"
10"
DISCONNECT
A p p l i c a t i o n
E n g i n e e r i n g
32"
ALARM LIGHT
63"
79"
OPERATOR
PANEL
CONDUCTIVITY
DISPLAY
TEMPERATURE
CONTROLLER
CIRCULATOR SYSTEM ON OFF L OW L EVEL SOLUTION TANK CIRCULATOR SUPP LY PUMP OFF ON ADDITIVE DRUM DRUM ETCH L OW L EVEL L OW L EVEL
TEMPERATURE CONTROL
PFC PORTABLE FOUNTAIN CIRCULATOR-5 CONDUCTIVITY
emergency
stop
E-STOP