American Energy Systems O2 Catalytic - Manual (Page 31)

31
GLASS-CERAMIC SPECIFICATIONS
Manufacturer: Euro Kera Window Type: Glass-Ceramic, Kera Lite®
KERA LITE® glass-ceramic has a thermal endurance far exceeding that of normal tempered glass. KERA LITE® is
designed to operate at temperatures ranging from -400
0 F to +1400 0 F. Despite its superior thermal properties, KERA
LITE® stove windows should be treated with care. This glass-ceramic can still be scratched or broken by mechanical
abuse. When cleaning the window, use only non-caustic, nonabrasive cleaners. Country Flame uses KERA LITE®
glass-ceramic that is 0.197 inches thick +/- 0.008 inches. The KERA LITE® glass is custom cut to fit Country Flame
stoves. If problems occur with stove glass, contact Country Flame or an authorized local Country Flame dealer for
assistance.
GLASS-CERAMIC CLEANING
NEVER ATTEMPT TO CLEAN HOT STOVE GLASS. Applying cleaner to hot glass may cause burns, emit hot
noxious fumes, and will increase the chances the glass will stain. Creosote and soot that attaches to the glass, caused by
burning wood fuel, may be removed with Speedy White Hearth and Stove Cleaner or Cook Top Cleaning Crème available
at appliance centers or call 1-800-872-8855 to obtain the proper cleaning material. BE CAREFUL, the cleaning solution
can stain surrounding material, especially after the creosote has dissolved and runs or drips off the glass. Hint: put down a
generous amount of newspaper in the surrounding area. After using any cleaner always remove all residue by washing the
glass with water or conventional window cleaner spray. Any remaining residue will stain the glass when it is heated. The
glass door on a Country Flame stove provides the enjoyment and beauty of viewing the fire while retaining the efficiency
of your stove. Although the brand of glass used in the Country Flame door has well established and recognized heat
resistant and strength characteristics, it can be broken through improper use. To achieve the maximum utility and safety
of your glass door, Country Flame advises the homeowner to observe the following use and safety tips:
1 Inspect the glass regularly for cracks or breaks. If you detect a crack or break, extinguish the fire immediately.
Contact Country Flame or an authorized local Country Flame Dealer for glass replacement. CAUTION: DO
NOT OVER TIGHTEN GLASS CLIPS OR GLASS BREAKAGE WILL OCCUR.
14. Do not slam the stove door or otherwise impact the glass. When closing the door, make sure that no logs or other
objects protrude to impact against the glass.
15. Glass will require cleaning but several techniques are advised to reduce creosote buildup.
a. Pull your fire forward to intensify the heat near the glass.
b. Each Country Flame stove is equipped with a glass air wash system. Opening the
combustion air slides slightly ensures enough air is entering the glass air wash system
to be more effective.
c. Very long, slow fires starve the glass air wash system and hasten creosote buildup.
d. Trim the gasket around the glass if it has curled and is interfering with the flow of air
over the inside of the glass.
16. Do not clean the glass with materials, which may scratch it (such as steel wool) or otherwise damage the glass.
17. The Glass-Ceramic, KERA LITE® used in Country Flame stoves is built to exacting standards and is expensive.
Replacement costs are high so be careful, properly clean and care for this ceramic glass thus enjoying years of
beautiful fire viewing.