CHAMPION CG Manual - Manual (Page 15)

7
Operation
MIX
Plug machine power cord into a
208-230VAC/60/1,15 A wall recep-
tacle. Turn main power and water
service ON.
Remove lower wash tank scrap screen.
Make sure a glass
is against the conveyor
stop switch, Push the rocker
switch UP to the ON
position until the wash
tank is full of water.
Then, push and hold each
chemical Prime button
until chemical supply
tubes are full.
The incoming cold water
supply temperature must
be a minimum temper-
ature of 75°F/24°C.
Adjust the temperature of
the incoming cold water temperature
by opening or closing the mixing valve
located between the hot water and the
cold water solenoid valves.
Check the cold water temperature
gauge and the cold water pressure
gauge as you adjust the mixing valve.
The minimum temperature should be
75°F/24°C. The pressure gauge should
read a flowing pressure
of 4-6 psi/24-36 kPa.
Check the wash tank
temperature gauge
for 140°F/60°C-
160°F/71°C.
Place glassware on
the conveyor.
The conveyor
stops automatically
when when
the clean glassware
operates the conveyor
stop switch.
Install the drain/
overflow tube into
the drain located
at the front of the
wash tank bottom.
Re-install the
scrap screen
removed
in Step 2.
Pull the chemical
pick-up tubes out
of the machine
Colored labels I.D. each tube
Place tube into its supply container.
On
Off
Flush
MIX
Pressure
Temperature
Wash Tank Heat
Prime
Prime
Prime
Label
Quick Operation Guide
The glass washing machine is designed
to automatically wash a wide variety of glassware.
The glass washer consists of a wash section and
rinse section. Glasses rotate on a conveyor
through each section. A wash tank in the lower
compartment holds heated wash water. The water
level in the wash tank is maintained by a float and
cam-operated switch. The wash tank water
temperature is controlled by a heater and a
thermostat. The rinse water is supplied from
the cold water supply. Chemicals are auto-
matically dispensed by built-in chemical pumps
1
2
3 4
6 5
7
8
7
4
6
7
8
1
2 3
5
Red
Label
Detergent Sanitizer
White
Blue
Label
Rinse-aid
Det.
Sani
R/A