JLG 800A_AJ ANSI Service Manual - Manual (Page 22)

SECTION 1 - SPECIFICATIONS
1-2 – JLG Lift – 3120740
Table 1-4. Deutz F4M2011F Specifications
Type Liquid Cooled (Oil)
Fuel Diesel
Oil Capacity
Cooling System
Crankcase
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 55 Amp, belt drive
Fuel Consumption
Low RPM
High RPM
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Battery 1000 Cold Cranking Amps, 210
minutes Reserve Capacity, 12 VDC
Horsepower 65 @ 2800 RPM, full load
Table 1-5. Deutz D2011L04 Specifications
Type Liquid Cooled (Oil)
Fuel Diesel
Oil Capacity
Cooling System
Crankcase
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2600
Alternator 55 Amp, belt drive
Fuel Consumption
Low RPM
High RPM
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Battery 1000 Cold Cranking Amps, 210
minutes Reserve Capacity, 12 VDC
Horsepower 64 @ 2600 RPM, full load
Table 1-6. Caterpillar 3044C
Type Four Stroke Cycle
Cylinders 4 in-line
Bore 3.70 inch (94 mm)
Stroke 4.72 inch (120 mm)
Aspiration turbocharged
Compression ratio 19:1
Displacement
203 in 3 (3.33 L)
Firing Order 1-3-4-2
Rotation (viewed from flywheel) Counterclockwise
Oil Capacity (w/filter) 10.6 quarts (10 L)
Cooling System (Engine Only) 5.8 quarts (5.5 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 60 Amp, belt drive
Table 1-7. Isuzu 4JB1
Type Water-cooled
Oil Capacity (w/filter) 8.5 Quarts (8.0 L)
Cooling System (Engine Only) 5.8 quarts (5.5 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 55 Amp, belt drive
Battery 1000 Cold Cranking Amps, 210
minutes Reserve Capacity, 12 VDC
Horsepower 66 @ 2800 RPM, full load
Table 1-8. GM 3.0L
Fuel Gasoline or Gasoline/LP Gas
No. of Cylinders 4
BHP
Gasoline
LP
83 hp @ 3000 rpm
75 hp @ 3000 rpm
Bore 4.0 in. (101.6 mm)
Stroke 3.6 in. (91.44 mm)
Displacement 181 cu.in. (3.0 L, 2966 cc)
Oil Capacity w/filter 4.5 qts. (4.25 L)
Minimum Oil Pressure
at idle
Hot
6 psi (0.4 Bar) @ 1000 rpm
18 psi (1.2 Bar) @ 2000 rpm
Compression Ratio 9.2:1
Firing Order 1-3-4-2
Max. RPM 2800