Snorkel TB65J - Manual (Page 4)

Table of Contents
TB65J – 0084248
Chapter 7 – Prestart Inspection
Operator’s Manual Holder ........................................25
Engine ......................................................................25
Oil Level ................................................................25
Coolant ..................................................................25
Radiator ................................................................26
Fuel Tank ...............................................................26
Fuel Line ...............................................................27
Air Filter .................................................................27
Charging System .................................................28
Cold Weather Start Kit ..........................................28
Electrical System ......................................................28
Battery Fluid Level ................................................28
Battery Terminals ..................................................28
Cables and Wiring Harness ......................................28
Hydraulic System......................................................28
Fluid Level .............................................................29
Fluid Filter .............................................................29
Hoses, Tubes, and Fittings ...................................29
Tires and Wheels ......................................................29
Lower Control Station ...............................................30
Operating Controls ................................................30
Emergency Stop ...................................................30
Emergency Power .................................................30
Emergency Lowering ................................................30
Level Sensor.............................................................3
Structures .................................................................3
Weldments ............................................................3
Boom Slide Pads ..................................................3
Extension Cylinder Slide Pads ..............................32
Wire Ropes ...........................................................32
Fasteners ..............................................................33
Upper Control Station ...............................................33
Guardrail System ..................................................33
Lanyard Anchors ...................................................33
Operating Controls ................................................33
Emergency Stop ...................................................34
Emergency Power .................................................34
All Motion Alarm........................................................34
Horn Button ..............................................................34
Electrical Power Outlet .............................................34
Platform Control Cover .............................................35
Drive Motion Alarm ...................................................35
Flashing Light ...........................................................35
Sandblast Protection Kit ...........................................35
Driving and Work Lights ...........................................35
Platform Glazier Package .........................................35
Placards and Decals.................................................36
Prestart Inspection Checklist ....................................4
Chapter 8 – Operation
Cold Weather Start-Up .............................................43
Engine Cold Weather Start Kit ..................................43
Cummins — Block Heater .....................................43
Deutz — Manifold Preheater .................................43
GM — Radiator Hose In-Line ................................43
Hydraulic System Cold Weather Warm-Up .............44
Hydraulic System Warm-Up Switch ......................44
Manually Warming The Hydraulic System ............44
Preparing for Operation ............................................44
Lower Controls .........................................................44
Upper Controls .........................................................45
Boom Operation ....................................................46
Driving and Steering .............................................46
Drive Speeds ........................................................47
Gradeability ..............................................................47
Theoretical Gradeability ........................................47
Actual Gradeability ................................................47
Percent vs. Degree of Slope .................................47
Driving on a Slope .................................................47
Calculating Percent Grade ....................................48
Machine Gradeability ............................................49
Electrical Power Outlet .............................................49
AC Generator ...........................................................49
Dual Fuel ..................................................................50
LP Fuel Tank .........................................................50
Air Line .....................................................................50
Driving Lights ............................................................50
Platform Work Lights ................................................5
Glazier Package .......................................................5
Platform Capacity ..................................................5
Platform Welder ........................................................5
Platform Capacity ..................................................52
Chapter 9 – Stowing and Transporting
Stowing .....................................................................53
Tucked Stow ........................................................53
Transporting .............................................................53
Driving ...................................................................54
Winching ...............................................................54
Hoisting .................................................................55
Securing for Transport ..........................................56
Chapter 10 – Emergency Operation
Emergency Power System .......................................57
Lower Controls ......................................................57
Upper Controls ......................................................57
Emergency Lowering ................................................58
Towing ......................................................................59
Chapter 11 – Troubleshooting
Troubleshooting Chart ..............................................6
Appendix A – Glossary
Limited Warranty