Snorkel TB65J User Manual
Page 31
Chapter 7 – Prestart Inspection
TB65J – 0084248
27
The fuel level gauge on LPG fuel tanks is behind the
rear cowling door on the left side of the machine (refer
to Figure 7.5). The gauge measures the level of fluid in
/6ths of a tank or says full or add.
Figure 7.5 – LPG Tank Fuel Gauge
To check the fuel level:
. Open the door to access the fuel gauge.
2. Read the fuel level indicated on the gauge.
3. If necessary, add fuel.
Note
Refer to Chapter 2 for fuel grade specifications.
4. Make sure the cap is securely fastened on gasoline
or diesel tanks.
Use the following procedure to change the LPG tank.
. Close the shutoff valve (refer to Figure 7.6).
Figure 7.6 – LPG Tank
2. Remove the fuel line from the tank using the quick
disconnect fitting.
3. Pull on each latch to release the straps.
4. Carefully lift the tank from the cradle.
5. Place a full tank in the cradle making sure the slot in
the tank aligns with the pin.
6. Latch both straps to secure the tank.
7. Connect the fuel line and open the shutoff valve.
Fuel Line
To inspect the fuel line:
. Visually inspect the entire length of the fuel line start-
ing at the fuel tank.
2. Trace the line to the engine, inspecting for leaks and
damage.
Air Filter
The air filter gauge (refer to Figure 7.7) has an indicator
to show when the filter needs replaced.
Figure 7.7 – Gauge Panel
To inspect the air filter:
. Turn the battery disconnect switch on and close the
cowling door.
2. On dual fuel machines, set the fuel switch to either
LPG or gasoline.
3. At the lower controls, place the emergency stop
switch in the on position.
4. Insert the key into the start switch and turn the engine
on.
5. Check the clear zone after running the engine for 30
seconds.
• If the indicator is red, replace the filter.
• If the indicator is clear, the filter is OK.
6. Shut off the engine.
Air Filter Gauge
Reset Button
Engine
Temperature
Gauge
Ammeter – Cummins and Deutz
Voltmeter – General Motors
Vertical Scale
Latch
Shutoff Valve
Slot
Quick
Disconnect
Fitting
Pin