Controlled Products Systems Group SL58510011G3 - Manual (Page 2)

2
CARTON INVENTORY
Before beginning your installation check that all components
were provided and received undamaged. Refer to list below
for factory provided parts.
Description Qty.
Safety Gate Brochure 1
Gate Bracket 2
Take-Up Bolt 2
Nickel Plated Chain #50 1
U-Bolt 2" 5/16-18 4
U-Bolt 3" 3/8-16 4
Square Head Set Screw 7/16-14 4
Hex Nut 1/2-13 4
Flange Nut 5/16"-18 8
Flange Nut 3/8"-16 8
Flat Washer 3/8" 8
Flat Washer 1/2" 4
Lock Washer 1/2" 4
Antenna 1
HARDWARE KIT
SL585/SL595 (K77-34846)
IMPORTANT NOTES
• BEFORE attempting to install, operate or maintain the operator,
you MUST read and fully understand this manual and follow all
safety instructions.
• DO NOT attempt repair or service of your commercial door and
gate operator unless you are an Authorized Service Technician.
T A B L E O F C O N T E N T S
OPERATOR SPECIFICATIONS
Carton Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2
Operator Dimensions and Horsepower Chart . . . . . . . . . . . . . . .3
UL325 Model Classifications . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
OPERATOR WARNINGS
Safety Installation Information . . . . . . . . . . . . . . . . . . . . . . . . . .5
Suggested Entrapment Protection Device Locations . . . . . . . . . .6
Safety Precautions for Open Roller Gates . . . . . . . . . . . . . . . . . .7
Warning Sign Placement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7
WIRING
Power Wiring Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8
INSTALLATION
Pad Mounting (SL585 only) . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Post Mounting (SL585 & SL595) . . . . . . . . . . . . . . . . . . . . . . .10
Install Gate Bracket and Drive Chain . . . . . . . . . . . . . . . . . . . . .11
Available Conduit Access for the Electrical Box . . . . . . . . . . . . .12
On/Off Switch Power Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . .12
Manual Disconnect . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12
ADJUSTMENT
Limit Switch Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
RPM Sensor Adjustment (Hall Effect) . . . . . . . . . . . . . . . . . . . .13
Gate System Test Procedures . . . . . . . . . . . . . . . . . . . . . . . . . .13
Install Vent Plug . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
UL325 Entrapment Protection . . . . . . . . . . . . . . . . . . . . . . .14-15
Control Board Illustration . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Program Settings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Control Connection Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . .17
Radio Reciever . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18-19
Accessory Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19-20
Earth Ground Rod Installation . . . . . . . . . . . . . . . . . . . . . . . . . .21
Sequenced Access Management System . . . . . . . . . . . . . . . . .22
OPERATION AND MAINTENANCE
Operator Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23
Solenoid Actuated Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Friction Clutch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .24
Control Board Programming and Features . . . . . . . . . . . . . .24-25
Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .26-27
Self-Regulating Heater Accessory . . . . . . . . . . . . . . . . . . . . . . .28
Single Phase Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . .29
Single Phase Schematic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30
Three Phase Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . .31
Three Phase Schematic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32
REPAIR PARTS
Repair Parts - Model SL585 . . . . . . . . . . . . . . . . . . . . . . . . . . .33
Illustrated Parts - Model SL585 . . . . . . . . . . . . . . . . . . . . . . . . .34
Repair Parts - Model SL595 . . . . . . . . . . . . . . . . . . . . . . . . . . .35
Illustrated Parts - Model SL595 . . . . . . . . . . . . . . . . . . . . . . . . .36
Electrical Box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37
Safety Accessories for Secondary Entrapment Protection . . . .38
NOTES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39
WARRANTY POLICY AND SERVICE . . . . . . . . . . . . . . . .40
When you see these Safety Symbols and Signal Words on the
following pages, they will alert you to the possibility of SERIOUS
INJURY or DEATH if you do not comply with the warnings that
accompany them. The hazard may come from something
mechanical or from electric shock. Read the warnings carefully.
When you see this Signal Word on the following pages, it will
alert you to the possibility of damage to your gate and/or the gate
operator if you do not comply with the cautionary statements that
accompany it. Read them carefully.
Mechanical
Electrical
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNING
CAUTION CAUTION
WARNING
WARNING
PRECAUCIÓN ADVERTENCIA
ADVERTENCIA ADVERTENCIA
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNING WARNING
CAUTION
WARNING
WARNING
PRECAUCIÓN ADVERTENCIA
ADVERTENCIA ADVERTENCIA
ATTENTION
AVERTISSEMENT AVERTISSEMENT
AVERTISSEMENT
WARNING
CAUTION
WARNING WARNING
WARNING
PRECAUCIÓN ADVERTENCIA
ADVERTENCIA ADVERTENCIA