State Industries SBD85 500 - Manual (Page 53)

SBD TANK TYPE HEATERS
SERVICE HANDBOOK
Technical Training Department
Ashland City, TN ©2003
52
SBD SERVICE CHECKLIST
(This service checklist may be photo copied to assist with SBD service call.)
This checklist is intended to aid the Service Agent in determining that the State SBD
Water Heater has been properly installed and is operating correctly. Because the
circumstances of each installation may vary greatly, it is not intended to be an all-
inclusive list of the problems that the Service Agent may encounter. Any item checked
"no" on this list should be thoroughly investigated and corrective action taken, if
required.
SERVICE
AGENT INSTALLATION DATE
MODEL NUMBER SERVICE DATE
SERIAL NUMBER LOCATION ADDRESS
GAS TYPE - CHECK ONE
NATURAL PHONE( ) ___ - ____
PROPANE
I. Check Clearances (circle answer)
A. Are exterior clearances adequate? yes no
B. Are interior clearances adequate? yes no
Comments:
II.
Check Makeup Air Requirements
A. Is the quantity of make-up air adequate per the National Fuel Gas Code? yes no
Comments:
B. Is the quality of make-up air adequate? yes no
Comments:
III.
Gas Pressure (fill in blank)
A. Supply gas pressure inches of W.C.
B. Manifold gas pressure (main burner) inches of W.C.
Comments:
IV.
Venting (check)
A. Properly sized per the National Fuel Gas Code? yes no
B. Does the installation have mechanically assisted venting? yes no
If
so, is it operational? yes no
Comments: