Hearth and Home Technologies DV3732SBIL - Manual (Page 3)

3 Hearth & Home Technologies • DV3732SBI, DV3732SBIL • 2215-900 Rev. G • 2/13
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Used to address practices not related to personal injury.
Table of Contents
A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
B. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . 5
1 Listing and Code Approvals
A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
B. Tempered Glass Specifi cations . . . . . . . . . . . . . . . . . . . . . 7
C. BTU Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 7
E. Non-Combustible Materials Specifi cation. . . . . . . . . . . . . . 7
F. Combustible Materials Specifi cation . . . . . . . . . . . . . . . . . 7
G. Electrical Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
H. Requirements for the Commonwealth of Massachusetts . . 8
User Guide
2 Operating Instructions
A. Gas Fireplace Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
B. Your Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
C. Fan Kit (optional) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
D. Decorative Doors and Fronts . . . . . . . . . . . . . . . . . . . . . . 10
E. Clear Space . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
F. Fixed Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
G. Remote Controls, Wall Controls and Wall Switches . . . . . 10
H. Before Lighting Fireplace . . . . . . . . . . . . . . . . . . . . . . . . . 10
I. Lighting Instructions (IPI) . . . . . . . . . . . . . . . . . . . . . . . . . 11
J. After Fireplace is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
K. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 12
3 Maintenance and Service
A. Maintenance Tasks-Homeowner . . . . . . . . . . . . . . . . . . . 13
B. Maintenance Tasks-Qualifi ed Service Technician . . . . . . 14
4 Getting Started
Installer Guide
A. Typical Appliance System. . . . . . . . . . . . . . . . . . . . . . . . . 15
B. Design and Installation Considerations . . . . . . . . . . . . . . 16
C. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . 16
D. Inspect Appliance and Components . . . . . . . . . . . . . . . . . 16
5 Framing and Clearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . 17
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . 18
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
D. Mantel and Wall Projections . . . . . . . . . . . . . . . . . . . . . . . 19
6 Termination Locations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 20
7 Vent Information and Diagrams
A. Approved Pipe . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
B. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
C. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
D. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22
E. Use of Flex Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
F. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24
8 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 36
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 36
C. Install the Ceiling Firestop . . . . . . . . . . . . . . . . . . . . . . . . 37
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 38
9 Appliance Preparation
A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
B. Rear Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 41
10 Installing Vent Pipe (DVP and SLP Pipe)
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . . 42
B. Assemble Vent Sections (SLP Pipe Only) . . . . . . . . . . . . 43
C. Assemble Slip Sections . . . . . . . . . . . . . . . . . . . . . . . . . . 43
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 44
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 44
F. Install Decorative Ceiling Components (SLP only). . . . . . 45
G. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 46
H. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 46
I. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 47
J. Install Decorative Wall Components (SLP only) . . . . . . . . 47
K. Heat Shield Requirements for Horizontal Termination . . . 47
L. Install Horizontal Termination Cap (DVP and SLP Pipe) . 48
11 Gas Information
A. Fuel Conversion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
B. Gas Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . 49
12 Electrical Information
A. Wiring Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
B. Intellifi re Ignition System Wiring . . . . . . . . . . . . . . . . . . . . 50
C. Optional Accessories Requirements . . . . . . . . . . . . . . . . 50
D. Electrical Service and Repair . . . . . . . . . . . . . . . . . . . . . . 50
E. Junction Box Installation. . . . . . . . . . . . . . . . . . . . . . . . . . 52
F. Wall Switch Installation for Fan (Optional) . . . . . . . . . . . . 52


