John Deere J BACKHOES 310SJ TMC - Manual (Page 39)

Net engine power is with standard equipment including air
cleaner, exhaust system, alternator, and cooling fan at test
conditions specified per ISO9249. No derating is required up
to 10,000-ft. (3050 m). Specifications and design are subject to change without notice. Wherever applicable, specifications are in accordance with ISO standards.
Except where otherwise noted, these specifications are based on a 310SJ TmC unit with 19.5L-24-in. 10PR (R4) tubeless rear and
11L-16-in. 12PR (F3) front tires, 1.12-cu.-yd. (0.86 m
3 ) loader bucket, and 24-in. x 7.5-cu.-ft. (610 mm x 0.21 m 3 ) backhoe bucket;
and a 410J TmC unit with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in. 12PR (F3) front tires, 1.30-cu.-yd. (1.00 m 3 ) loader
bucket, and 24-in. x 7.5-cu.-ft. (610 mm x 0.21 m 3 ) backhoe bucket.
310SJ 410J
TMC TMC
Engine
l l meets EPA Tier 3/EU Stage IIIA emissions
l John Deere model 4045HT054 – 4.5 liter, 70 kW
(94 net peak hp) turbocharged, isolation mounted
l John Deere model 4045HT054 – 4.5 liter, 73 kW
(98 net peak hp) turbocharged, isolation mounted
l l Vertical spin-on engine oil filter
l l Vertical spin-on fuel filter with water separator
l l Oil-to-water engine oil cooler
l l Antifreeze, –37°C (–34°F)
l l Coolant recovery tank
l l Serpentine belt with automatic belt tensioner
l l Suction-type cooling fan
l l Enclosed safety fan guard
s s High ambient temperature engine cooling
l l Dual-element dry-type air cleaner
l l muffler, under hood with curved-end exhaust
stack
s s Chrome exhaust extension
s s Cold-start package – electric ether starting aid
and engine coolant heater, 1,000 watts
Powertrain
l l PowerShift Tm transmission: Torque converter with
electrically actuated twist grip F-N-R with neutral
safety switch interlock (1st through 4th gears)
l l Transmission oil cooler
l l Vertical spin-on transmission filter
l l Transmission remote oil-sampling port
l l Differential lock, electric foot-actuated
l l Planetary final drives
l l Power-assisted hydraulic service brakes (con-
form to ISO 3450): Inboard, wet multi-disc, self-
adjusting and self-equalizing
l l Parking/emergency brake with electric switch
control (conforms to ISO 3450): Spring applied,
hydraulically released wet multi-disc / Indepen-
dent of service brakes
l l Hydrostatic power steering with emergency
manual mode
l l mechanical-front-wheel drive with traction
control limited-slip differential: Electric on/off
control / Sealed axle
s s Rear wheel spacers for use with chains
s s mFWD driveshaft guard
Backhoe
l Extendable dipperstick, 1.07-m (3 ft. 6 in.)
extension
l Extendable dipperstick, 1.22-m (4 ft.) extension
l Heavy-duty backhoe bucket cylinder
l l Backhoe transport lock lever
l l Swing lock pin stored in operator’s station
l l Stabilizers with 2-direction anti-drift valves
l l Pivoting stabilizers with reversible pads
l Extended (long) stabilizers with reversible pads
l l Less bucket, with bucket pins
s s Standard-duty backhoe bucket with lift loops
s s Heavy-duty backhoe bucket with lift loops
s s Severe-duty backhoe bucket with lift loops
s s Backhoe coupler for “C,” “D,” “E,” “G,” and “J”
Series John Deere, Case, and Cat buckets
l l Auxiliary backhoe valve for swingers, thumbs,
etc. with auxiliary plumbing
l l Auxiliary backhoe valve for hammers and com-
pactors with auxiliary plumbing
310SJ 410J
TMC TMC
Backhoe (continued)
s s Hydraulic thumb
Loader †
l l Loader bucket anti-spill (settable height)
l l Return-to-dig feature (settable / activates from
curled or dumped bucket position)
l l Armrest-mounted joysticks with electric clutch
cutoff, auxiliary loader control, extendible dipper-
stick control, mFWD control (momentary), mFWD
control (permanent), proportional auxiliary back-
hoe control, and horn
l l Auxiliary loader hydraulics with thumb-switch
control
l l mini joystick for simultaneous control of loader
and backhoe
l l Electric bucket-level indicator
l l Loader boom service lock
l l Ride control
l l Less bucket, with bucket pins
l l High-visibility loader arms
l l Tool-carrier loader: Front loader hydraulic quick-
coupler / Parallel lift (selectable) / Return-to-carry
(selectable / height set) / Boom-height kickout
Hydraulic System
l l 159-L/min. (42 gpm) axial piston pump
l l Independent hydraulic reservoir
l l “O”-ring face seal connectors
l l 6-micron vertical spin-on filter
Electrical System
l l 12-volt system
l l 120-amp alternator
l l Dual batteries with 380-min. reserve capacity
and 1,900 CCA
l l Dual battery master-disconnect switch
l l Positive terminal battery cover
l l Blade-type multi-fused circuits
l l By-pass start safety cover on starter
l l Jump/auxiliary start terminal
Lights
l l Turn signal/flashing (2 front and 2 rear)
l l Rear stop and tail (2)
l l Rear reflectors (2)
Operator’s Station
l l modular-design ROPS/FOPS cab with molded
roof (conforms to SAE J1040): Isolation mounted
l l Left and right access
l l Slip-resistant steps and ergonomically located
handholds (conform to SAE J185)
l l molded floor mats
l l Headliner
l l Coat hook
l l 12-volt outlets (2)
l l Built-in beverage and Thermos bottle holders
l l Built-in Operator’s manual storage compartment
with manual
l l Auto-idle
l l Interior rearview mirror
l l Interior front-view mirror
s s Outside rearview mirrors
l l Stabilizer controls in the left armrest
l l Rotary-dial hand throttle
l l Suspended foot throttle
l l Tilt steering, infinitely adjustable
310SJ 410J
TMC TMC
Operator’s Station (continued)
l l Horn in side console
l l Seat belt, 76-mm (3 in.), with retractor
l l Key start switch with electric fuel shutoff
l l Electronic anti-theft enabled through monitor
l l Engine coolant temperature gauge, illuminated
electronic, with audible warning
l l Oil temperature gauge, illuminated electronic,
with audible warning
l l Fuel gauge, illuminated electronic
l l Digital display of engine hours, engine rpm, and
system voltage
l l monitor system with audible and visual warn-
ings: Engine air restriction indicator / Low alter-
nator voltage indicator / Engine oil pressure
indicator with audible warning / Hydraulic filter
restriction indicator / Parking brake on/off indi-
cator with audible warning / Seat belt indicator /
Low brake pressure / machine diagnostic infor-
mation via 4-pushbutton/LCD operator interface
l l TMC Canopy: Air-suspension deluxe vinyl
swivel seat with lumbar adjustment and arm-
rests (fully adjustable) / Tilt steering, infinitely
adjustable / Additional halogen work lights (6),
32,500 candlepower each (2 front, 2 rear, and
2 side docking)
l l Ultimate Cab: Air-suspension deluxe fabric
swivel seat with lumbar adjustment / Tilt steer-
ing / Am/Fm/weather-band radio with CD player /
Sun visor / Headliner, dome light, left and right
cab doors, tinted safety glass, windshield wiper
(1 rear and 1 front), front windshield wiper, fresh-
air intake, and heater/defroster/pressurizer
(11.7-kW [40,000 Btu/hr.] heater) / Additional
halogen work lights (6), 32,500 candlepower
each (2 front, 2 rear, and 2 side docking) / Air
conditioner (7.6-kW [26,000 Btu/hr.] output and
CFC-free R134a refrigerant)
Overall Vehicle
l l 1-piece unitized construction mainframe
l l Vehicle tie-downs (2 front and 2 rear)
l l Remote grease bank for front axle
l l Heavy-duty front bumper
s s 204-kg (450 lb.) front counterweight
s s 317-kg (700 lb.) front counterweight
s s 454-kg (1,000 lb.) front counterweight
s s 567-kg (1,250 lb.) front counterweight
s s 657-kg (1,450 lb.) front counterweight
s s Rubber grille bumpers
l l Fuel tank, 155 L (41 gal.), ground-level fueling
l l 2-position easy-tilt hood
l l Extended grille frame
l l Removable toolbox with padlock hasp
l l Vandal protection for locking engine hood, tool-
box, hydraulic reservoir, and fuel tank
l l Reverse warning alarm
s s Sound-reduction package
l l Dent-resistant full-coverage rear fenders
s s JDLink Tm wireless communication system
(available in specific countries; see your
dealer for details)
† See dealer for range of heavy-duty, multipurpose, and
coupler buckets and forks.
310SJ / 410J WITH TOTAL MACHINE CONTROL TM
Key: l Standard equipment s Optional equipment *See your John Deere dealer for further information.
DKAJLBH Page 39