John Deere J BACKHOES 310SJ TMC - Manual (Page 38)

Net engine power is with standard equipment including air
cleaner, exhaust system, alternator, and cooling fan at test
conditions specified per ISO9249. No derating is required up
to 1500-m (5,000 ft.) altitude for the 310J and up to 3050-m
(10,000 ft.) for the 310J with optional altitude-compensating
turbocharger, the 310SJ, the 410J, and the 710J. Specifications and design are subject to change without notice. Wherever applicable, specifications are in accordance with ISO standards.
Except where otherwise noted, these specifications are based on a 310J unit with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in.
12PR (F3) front tires, 0.76-m
3 (1.00 cu. yd.) loader bucket, and 610-mm x 0.18-m 3 (24 in. x 6.5 cu. ft.) backhoe bucket; a 310SJ unit
with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in. 12PR (F3) front tires, 0.86-m 3 (1.12 cu. yd.) loader bucket, and 610-mm x
0.21-m 3 (24 in. x 7.5 cu. ft.) backhoe bucket; a 410J unit with 19.5L-24-in. 10PR (R4) tubeless rear and 11L-16-in. 12PR (F3) front
tires, 1.00-m 3 (1.30 cu. yd.) loader bucket, and 610-mm x 0.21-m 3 (24 in. x 7.5 cu. ft.) backhoe bucket; and a 710J unit with 21L-28
R-4 (14) rear and 14.5/75-16.1 SL F-3 (10) front tires, 1.24-m 3 (1.62 cu. yd.) loader bucket, and 610-mm x 0.31-m 3 (24 in. x 11.1 cu. ft.)
backhoe bucket.
310J 310SJ 410J 710J Engine
l l l l meets EPA Tier 3/EU Stage IIIA emissions
l John Deere model 4045HT054 – 4.5 liter, 63 kW
(84 net peak hp) turbocharged, isolation mounted
l John Deere model 4045HT054 – 4.5 liter, 69 kW
(93 net peak hp) turbocharged, isolation mounted
l John Deere model 4045HT054 – 4.5 liter, 73 kW
(98 net peak hp) turbocharged, isolation mounted
l John Deere model 6068HT067 – 6.8 liter, 94 kW
(126 net peak hp) turbocharged, isolation mounted
l l l l Vertical spin-on engine oil filter
l l l l Vertical spin-on fuel filter with water separator
l l l l Oil-to-water engine oil cooler
l l l l Antifreeze, –37°C (–34°F)
l l l l Coolant recovery tank
l l l l Serpentine belt with automatic belt tensioner
l l l l Suction-type cooling fan
l l l l Enclosed safety fan guard
s s s High ambient temperature engine cooling
l l l l Dual-element dry-type air cleaner
l l l l muffler, under hood with curved-end exhaust stack
s s s Chrome exhaust extension
s s s s Cold-start package – electric ether starting aid
and engine coolant heater, 1,000 watts
Powertrain
l l l l PowerShift Tm transmission: Torque converter with
electrically actuated twist grip F-N-R with neutral
safety switch interlock (1st through 4th gears)
l l l l Transmission oil cooler
l l l l Vertical spin-on transmission filter
s s s s Transmission remote oil-sampling port
l l l l Differential lock, electric foot-actuated
l l l l Planetary final drives
l l l Power-assisted hydraulic service brakes (conform
to ISO 3450): Inboard, wet multi-disc, self-adjust-
ing and self-equalizing
l Full-power hydraulic service brakes (conform to
ISO 3450): Inboard, wet multi-disc, self-adjust-
ing and self-equalizing
l l l l Parking/emergency brake with electric switch
control (conforms to ISO 3450): Spring applied,
hydraulically released wet multi-disc / Indepen-
dent of service brakes
l l l l Hydrostatic power steering with emergency
manual mode
s s s s Non-powered front axle
l mechanical-front-wheel drive with open differ-
ential: Electric on/off control / Sealed axle
l l l mechanical-front-wheel drive with traction control
limited-slip differential: Electric on/off control /
Sealed axle
s s s s Rear wheel spacers for use with chains
s s s mFWD driveshaft guard
Backhoe
l Standard dipperstick, 4.34-m (14 ft. 3 in.)
digging depth
l Standard dipperstick, 4.42-m (14 ft. 6 in.)
digging depth
l Standard dipperstick, 4.83-m (15 ft. 10 in.)
digging depth
l Standard dipperstick, 5.44-m (17 ft. 10 in.)
digging depth
s s Extendable dipperstick, 1.07-m (3 ft. 6 in.)
extension
s Extendable dipperstick, 1.22-m (4 ft.) extension
s Extendable dipperstick, 1.37-m (4 ft. 6 in.)
extension
s Heavy-duty backhoe bucket cylinder option
l l l s 2-lever (Deere) backhoe controls
s s s l 2-lever pilot controls with pattern-selection feature
l l l l Backhoe transport lock lever
l l l l Swing lock pin stored in operator’s station
l l l l Stabilizers with 2-direction anti-drift valves
l l l l Pivoting stabilizers with reversible pads
s Extended (long) stabilizers with reversible pads
l l l l Less bucket, with bucket pins
s s s Standard-duty backhoe bucket with lift loops
310J 310SJ 410J 710J Backhoe (continued)
s s s s Heavy-duty backhoe bucket with lift loops
s s s Severe-duty backhoe bucket with lift loops
s s s Backhoe coupler for “C,” “D,” “E,” “G,” and “J”
Series John Deere, Case, and Cat buckets
s s s s Auxiliary backhoe valve for swingers, thumbs,
etc. with auxiliary plumbing
s s s s Auxiliary backhoe valve for hammers and com-
pactors with auxiliary plumbing
s s s Hydraulic thumb
Loader †
l l l l Loader bucket anti-spill (rollback)
l l l l Return-to-dig feature
l l l l Single-lever control with electric clutch cutoff
switch
l l l l Bucket-level indicator
l l l l Loader boom service lock
s s s s Auxiliary loader hydraulics with 2-lever control
s s s s Hydraulic coupler for buckets, forks, etc.
l l l l Less bucket, with bucket pins
l l l High-visibility loader arms
Hydraulic System
l 106-L/min. (28 gpm) gear pump, open center
system
l 136-L/min. (36 gpm) tandem gear pump, open-
center system
l 159-L/min. (42 gpm) axial piston pump, PCLS
system
l 197-L/min. (52 gpm) axial piston pump, PCLS
system
l l l l Independent hydraulic reservoir
l l l l “O”-ring face seal connectors
l l l l 6-micron vertical spin-on filter
Electrical System
l l l l 12-volt system
l l l l 90-amp alternator
l l l Single battery with 190-min. reserve capacity
and 950 CCA
s s s l Dual batteries with 380-min. reserve capacity
and 1,900 CCA
l l l l Positive terminal battery cover
l l l l Blade-type multi-fused circuits
l l l l By-pass start safety cover on starter
s s s s master disconnect switch
l l l l Jump/auxiliary start terminal
Lights
l l l l Halogen lights (4), 32,500 candlepower each
(2 front driving/working and 2 rear working)
l l l l Turn signal/flashing (2 front and 2 rear)
l l l l Rear stop and tail (2)
l l l l Rear reflectors (2)
Operator’s Station
l l l l modular-design ROPS/FOPS canopy with molded
roof (conforms to SAE J1040): Isolation mounted
l l l l Left and right access
l l l l Slip-resistant steps and ergonomically located
handholds (conform to SAE J185)
l l l l molded floor mats
l l l l Headliner
l l l l Coat hook
l l l l 12-volt outlets (2 cab, 1 canopy)
l l l l Built-in beverage and Thermos bottle holders
l l l l Built-in Operator’s manual storage compartment
with manual
l l l l Interior rearview mirror
s s s s Interior front-view mirror
s s s s Outside rearview mirrors
l l l l Rotary hand throttle
l l l l Suspended foot throttle
l l l l Horn
l l l l Seat belt, 76-mm (3 in.), with retractor
l l l l Key start switch with electric fuel shutoff
s s s s Electronic anti-theft enabled through monitor
l l l l Engine coolant temperature gauge, illuminated
electronic, with audible warning
l l l l Oil temperature gauge, illuminated electronic,
with audible warning
310J 310SJ 410J 710J Operator’s Station (continued)
l l l l Fuel gauge, illuminated electronic
l l l l Digital display of engine hours, engine rpm, and
system voltage
l l l l monitor system with audible and visual warnings:
Engine air restriction indicator / Low alternator
voltage indicator / Engine oil pressure indicator
with audible warning / Hydraulic filter restriction
indicator / Parking brake on/off indicator with
audible warning / Seat belt indicator / Low brake
pressure / machine diagnostic information via
4-push-button/LCD operator interface
l Basic Canopy: mechanical suspension deluxe
vinyl swivel seat with lumbar adjustment and
armrests (fully adjustable)
l l l Canopy: mechanical suspension deluxe vinyl
swivel seat with lumbar adjustment and armrests
(fully adjustable) / Tilt steering, infinitely adjustable /
Additional halogen work lights (6), 32,500 candle-
power each (2 front, 2 rear, and 2 side docking)
l Basic Cab: Air-suspension deluxe fabric swivel
seat with lumbar adjustment / Air conditioner
(7.6-kW [26,000 Btu/hr.] output and CFC-free
R134a refrigerant)
l l l l Premium Cab: Air-suspension deluxe fabric swivel
seat with lumbar adjustment / Tilt steering, infi-
nitely adjustable / Am/Fm/weather-band radio /
Sun visor / Headliner, dome light, left and right
cab doors, tinted safety glass, windshield wiper
(1 rear and 1 front), front windshield washer,
fresh-air intake, and heater/defroster/pressurizer
(11.7-kW [40,000 Btu/ hr.] heater) / Additional
halogen work lights (6), 32,500 candlepower
each (2 front, 2 rear, and 2 side docking)
l l l l Ultimate Cab: Air-suspension deluxe fabric swivel
seat with lumbar adjustment / Tilt steering, infi-
nitely adjustable / Am/Fm/weather-band radio
with CD player / Sun visor / Headliner, dome light,
left and right cab doors, tinted safety glass, wind-
shield wiper (1 rear and 1 front), front windshield
washer, fresh-air intake, and heater/defroster/
pressurizer (11/7-kW [40,000 Btu/hr.] heater) /
Additional halogen work lights (6), 32,500 candle-
power each (2 front, 2 rear, and 2 side docking) /
Air conditioner (7.6-kW [26,000 Btu/hr.] output
and CFC-free R134a refrigerant) / Ride control
Overall Vehicle
l l l l 1-piece unitized construction mainframe
l l l l Vehicle tie-downs (2 front and 2 rear)
l l l l Remote grease bank for front axle
l l l Front cover
s s s Heavy-duty front bumper
s s s 204-kg (450 lb.) front counterweight
s s s 317-kg (700 lb.) front counterweight
s s s 454-kg (1,000 lb.) front counterweight
s s s 567-kg (1,250 lb.) front counterweight
s s s 657-kg (1,450 lb.) front counterweight
l 422-kg (930 lb.) front counterweight
s 740-kg (1,630 lb.) front counterweight
s s s Rubber grille bumpers
l l l Fuel tank, 155 L (41 gal.), ground-level fueling
l Fuel tank, 261 L (69 gal.), ground-level fueling
l l l l 2-position easy-tilt hood
l l l Extended grille frame
l l l l Removable toolbox with padlock hasp
l l l l Vandal protection for locking monitor, engine
hood, toolbox, hydraulic reservoir, and fuel tank
l l l l Reverse warning alarm
s s s Sound-reduction package
l l l l Dent-resistant full-coverage rear fenders
s Boom-protection plate
s s s s JDLink Tm wireless communication system
(available in specific countries; see your dealer
for details)
† See dealer for range of heavy-duty, multipurpose, and coupler
buckets and forks.
310J / 310SJ / 410J / 710J BACKHOE LOADERS
Key: l Standard equipment s Optional equipment *See your John Deere dealer for further information.
DKAJLBH Page 38