Regency Horizon HZ33CE Small Gas Fireplace - Manual (Page 4)

4
Regency HZ33CE Gas Fireplace
TABLE OF CONTENTS
SAFETY LABEL
Copy of Safety Decal .....................................................5
REQUIREMENTS
MA Code - CO Detector.................................................6
DIMENSIONS
Unit Dimensions ............................................................7
4 sided faceplate Dimensions........................................7
Mantel Dimensions ........................................................7
INSTALLATION
Important Message ......................................................8
Before You Start ............................................................8
General Safety Information............................................8
Installation Checklist ......................................................9
Locating Your Gas Fireplace .........................................9
Clearances ..................................................................10
Mantel Clearances....................................................... 11
Mantel Leg Clearances................................................ 11
Framing & Finishing.....................................................12
Tile Finish ............................................................12
Clean Finish .........................................................13
Framing Dimensions....................................................14
Venting Introduction .....................................................15
Exterior Vent Termination Requirements .....................16
Regency
® Direct Vent fl ex System ..............................17
Rigid Pipe Venting Systems ........................................18
4" X 6-5/8" RigiD Pipe Cross Reference Chart ............19
Rigid Pipe Venting Arrangements ...............................21
Vertical Termination with Co-Linear Flex System ........22
Venting Arrangements - Vertical Terminations ............23
Unit installation with Horizontal termination .................28
Unit installation with Vertical Termination ....................29
Gas Line Installation ....................................................29
Pilot Adjustment ...........................................................30
High Elevation .............................................................30
886 S.I.T. Valve Description .........................................30
Gas Pipe Pressure Testing ..........................................30
Conversion from NG to LP ..........................................31
Wiring Diagrams .........................................................35
Profl ame system GT ...................................................35
Profl ame system GTM ................................................36
Installing the Optional Fan (Prior to unit installation) ...38
Optional fan Wiring Diagram ......................................39
Installing the Optional Fan (installed unit) ...................39
Optional Wall Thermostat ...........................................41
Battery Installation .......................................................41
Optional Remote Control .............................................41
Wall Switch ..................................................................41
Aeration Adjustment ....................................................41
Optional Refl ective Panel Installation ..........................42
Glass Crystals AND optional stones ............................43
Installation On Burner and Firebox Floor.....................43
Optional Spa Stones Installation .................................43
Optional log set Installation .........................................44
Glass screen guard and Glass Door installation .........47
Standard Flush Door and screen.................................47
Optional 4-sided faceplate installation .................48
Optional mantel installation ..................................49
OPERATING INSTRUCTIONS
Operating Instructions .................................................50
First Fire ......................................................................50
Lighting Procedure ......................................................50
Shutdown Procedure ...................................................50
Normal Operating Sounds of Gas Appliances .............50
Copy of Lighting Plate Instructions ..............................51
MAINTENANCE
Maintenance Instructions.............................................52
General Vent Maintenance ..........................................52
Glass Door...................................................................52
Glass Replacement .............................................52
Valve Tray Replacement ..............................................53
PARTS LIST
Main Assembly ............................................................54
Accessories .................................................................55
WARRANTY
The Warranty: Limited Lifetime ...................................59