Landoll XO108/XO108-1 X-Fold Pulverizer User Manual
Page 6
6J862
683rev501
SAFETY
SUGGESTIONS
Federal law requires you to explain the safety and operating instructions furnished with this machine
to all employees before they are allowed to operate the machine. These must be repeated to the em-
ployees at the beginning of each season. Be sure to observe and follow the instructions for the safety
of anyone operating or near the machine.
Investigation has shown that nearly one-third of all farm accidents are caused by careless use of ma-
chinery. You can do your part in improving safety by observing the following suggestions. Insist that
all people working with you or for you abide by them.
1.
Do not stand between the tractor and implement when attaching or detaching implement un-
less both are not moving.
2.
Do not make adjustments or lubricate machine while it is in motion.
3.
Do not allow anyone to ride on tractor or machine.
4.
Always use transport lock when transporting machine.
5.
Do not transport at speeds over 20 mph.
6.
Avoid sudden stops or turns when transporting because weight of machine may cause opera-
tor to lose control of tractor. Use a tractor heavier than machine. Do not allow tractor drawbar
to swing when transporting.
7.
Use caution when towing behind articulated steering tractors; fast or sharp turns may cause
the machine to slip sideways.
8.
When transporting the machine on a road or highway, use adequate warning symbols, reflec-
tors, lights, and slow moving vehicle signs as required.
9.
Lower machine to ground when not in use.
10.
Block machine so it will not roll when unhitched from tractor.
11.
Relieve pressure in hydraulic lines before uncoupling hydraulic hoses from tractor. On most
tractors this can be done by operating valves after engine is stopped.
12.
Securely block machine when working on or under it to prevent injury in case of hydraulic
failure or inadvertent lowering by another person.
13.
Do not allow anyone near the machine when folding or unfolding the wings.
14.
Fold wings on as level a surface as possible.
15.
Install safety chain between the pulverizer and the tractor. See page 19 of this manual and/or
tractor manual.
16. Escaping
hydraulic
fluid under pressure can have sufficient force to penetrate the skin,
causing serious personal injury. Before applying pressure to the system, be sure all
connections are tight and that lines and hoses are not damaged.
17. Hydraulic
fluid escaping from a very small hole can be almost invisible. Use a piece of
cardboard or a piece of wood, rather than hands, to search for suspected leaks.
Page 4